2007 VOLVO VNM

POWER TRAIN:CLUTCH ASSEMBLY

Volvo Trucks North America (Volvo) is recalling certain model year 2007-2014 VAH, VHD, VNL, VNM, and VT models. The affected vehicles were built without a redundant clutch disengagement switch. Without a redundant switch, a loss of signal from the brake air pressure switch can prevent the clutch fr

STEERING

ON CERTAIN TRUCKS, THE NUT USED TO RETAIN THE STEERING SHAFT MAY OR MAY NOT BE A LOCK NUT THAT HAS THE LOCKING FEATURE. A LOCK NUT IS REQUIRED TO PROVIDE ADDITIONAL RESISTANCE TO ENSURE THAT THE NUT DOES NOT COME LOOSE.

TRAILER HITCHES:FIFTH WHEEL ASSEMBLY

ON CERTAIN TRUCKS EQUIPPED WITH A SAF HOLLAND SIMPLEX FIFTH WHEEL, THE LEVER ARM PIVOT BOLT MAY HAVE BEEN OVER TIGHTENED. AN OVER TIGHTENED PIVOT BOLT CAN DISTORT THE PIVOT BOLT SPACER SLEEVE, WHICH MAY PREVENT THE FIFTH WHEEL LATCH JAW FROM CLOSING AND LATCHING SECURELY AROUND THE TRAILER KING PI

VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR

VOLVO TRUCKS IS RECALLING 127,764 MY 2001-2008 VHD, VNL, VNM, AND MY 2005-2008 VT TRUCKS. A SEAL MAY FAIL ALLOWING WATER AND CONTAMINANTS TO SEEP INTO THE WINDSHIELD WIPER MOTOR.

POWER TRAIN:AXLE ASSEMBLY

ON CERTAIN TRUCKS, THE AXLE HOUSINGS MAY HAVE BEEN MANUFACTURED WITH STEEL THAT WAS OUT OF SPECIFICATION WHICH COULD RESULT IN A FATIGUE FAILURE OVER TIME.

ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS

ON CERTAIN HEAVY DUTY TRUCKS, THE CIRCUIT PROTECTION (I.E. AUTOMATIC CIRCUIT BREAKERS) USED TO PROTECT THE VEHICLE LIGHTING SYSTEM MAY NOT PROVIDE ADEQUATE PROTECTION.

POWER TRAIN:DRIVELINE

ON CERTAIN TRUCKS EQUIPPED WITH ARVINMERITOR RPL20 HIGH ANGLE INTERAXLE DRIVESHAFTS, AN IMPROPER SEATED OR MISSING SNAP RING CAN RESULT IN THE BEARING CUP TO SEPARATE FROM THE SLIP YOKE SUB-ASSEMBLY. THE UNIVERSAL JOINT CROSS COULD THEN CONTACT THE SLIP YOKE CASTING AND EVENTUALLY CAUSE THE EAR WOR

FUEL SYSTEM, DIESEL

ON CERTAIN TRUCKS, AN UNPROTECTED LEAD IN THE THERMOSWITCH OF THE HEATER MAY MAKE CONTACT WITH ANOTHER POST POSSIBLY CREATING A SHORT CIRCUIT, WHICH CAN RESULT IN CONTINUOUS OPERATION OF THE HEATING ELEMENT.

CONSUMER WRITES IN REGARDS TO TWO HEAD ON COLLISIONS AND PROBLEM WITH AIRBAG DEPLOYMENT *TGW THE CONSUMER STATED THE COLLISIONS INVOLVED TWO DIFFERENT VOLVO TRACTORS.

TL* CONTACT OWNS A 2007 VOLVO VNM670. THE CONTACT STATED THAT THE VEHICLE WAS INVOLVED IN A CRASHED AND THE AIR BAGS FAILED TO DEPLOY. THE DRIVER SUSTAINED MINOR INJURIES. A POLICE REPORT WAS FILED. THE DEALER WAS MADE AWARE OF THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS DESTROYED. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 450,000.

Mileage: 450,000

2007 VOLVO VNM CONVENTIONAL STALLED ON THE HIGHWAY. *BF WHEN THE TRUCK STALLED, THE DRIVER PANICKED AND ABRUPTLY TURNED HIS VEHICLE AND STUCK THE LANE EXTENDER. OHIO TRAFFIC CRASH REPORT # 10-0289-91 UPDATED 05/03/10 *BF