2018 VOLVO VNL
12 complaints filed with NHTSA.
Complaints by Component
| Component | Count |
|---|---|
| POWER TRAIN | 3 |
| STEERING | 2 |
| AIR BAGS | 1 |
| SERVICE BRAKES | 1 |
| VEHICLE SPEED CONTROL | 1 |
| ELECTRICAL SYSTEM | 1 |
| ENGINE | 1 |
| VEHICLE SPEED CONTROL:THROTTLE | 1 |
| FUEL SYSTEM, GASOLINE | 1 |
Recalls (5)
ENGINE AND ENGINE COOLING:ENGINE:DIESEL
Volvo Trucks North America (Volvo) is recalling certain 2016-2019 Volvo VNL trucks equipped with Cummins ISX15 diesel engines. In certain driving conditions, such as on a long down-hill grade, the fuel line may burst if the fuel pump cooling circuit screen becomes restricted.
STRUCTURE:BODY
Volvo Trucks North America (Volvo Trucks) is recalling certain 2018-2020 VNL and VNX vehicles configured as 740 and 760 sleeper models. The sleeper bunk window may detach and fall from the vehicle.
POWER TRAIN:CLUTCH ASSEMBLY
Volvo Trucks North America (Volvo) is recalling certain 2018-2019 Volvo VNL vehicles equipped with an automated manual transmission. An internal component in the clutch assembly may fail, possibly resulting in unintended vehicle movement.
ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS
Volvo Trucks North America (Volvo Trucks) is recalling certain 2018-2020 VAH, VHD, VNL, and VNR vehicles. The fuse in the transmission circuit may blow, preventing the transmission from shifting.
EQUIPMENT:OTHER:LABELS
Volvo Trucks North America (Volvo) is recalling certain 2018-2021 VNL and VNR buses. The Gross Axle Weight Rating (GAWR) for the rear drive axles stated on the Federal Certification Label exceeds the rating of the wheel hubs. As such, these vehicles fail to comply with the requirements of 49 CFR P
Recent Complaints
The contact owns a 2018 Volvo VNL Truck. The contact stated while driving at various speeds, the vehicle was lunging forward and failed to properly respond while depressing the accelerator pedal. There was no additional information provided. The vehicle was taken to the dealer, where it was diagnosed that the transmission clutch and transmission needed to be replaced. The vehicle was repaired; however, the power train warning light illuminated a week later. The vehicle was taken back to the deal
Mileage: 600,000
The contact owns a Volvo 2018 VNL64 Commercial vehicle. The contact stated that the vehicle would shut down while driving at various speeds. There was no further information provided. The vehicle was towed to the dealer, where the high pressure fuel pump filter, the differential pressure sensor, the rear wire harness were replaced. Additionally, the contact stated that the vehicle was experiencing transmission failures and would fail to respond intermittently while reversing. The dealer was noti
Mileage: 537,850
The contact owns a Volvo 2018 VNL64 Commercial vehicle. The contact stated that the vehicle would shut down while driving at various speeds. There was no further information provided. The vehicle was towed to the dealer, where the high pressure fuel pump filter, the differential pressure sensor, the rear wire harness were replaced. Additionally, the contact stated that the vehicle was experiencing transmission failures and would fail to respond intermittently while reversing. The dealer was noti
Mileage: 537,850
The contact owns a 2018 Volvo VNL. The contact stated that while approaching a stop, the clutch failed to disengage. The contact also stated that after decelerating, he depressed the accelerator pedal and the vehicle rolled back. The contact stated that the check warning light illuminated, indicating to check the transmission at the next stop. The vehicle was taken to the dealer where it was diagnosed and produced code: DTC-P107538 (Throttle Actuator Control Module) however, the contact was info
Mileage: 574,000
2019 COMPLAINED TO THE DEALER ABOUT UNEVEN WEARING OF THE FRONT TIRES THEY CHECKED ALIGNMENT THEN SAME COMPLAINT IN MARCH 2020 NO DEFECTS FIND THEN IN JULY 02 2020 I WAS UNABLE TO DRIVE BECAUSE OF VIBRATION , AFTER INSPECTION THEY FOUND PLASTIC BUSHINGS FOR BOTH KINGPINS WORN OUT AND REPLACED AS WHOLE SETS. MY COMPLAINT IS ABOUT PREMATURE FAILURE COMPONENTS AT 300000 MILES DUE TO USE OF PLASTIC BUSHINGS BY MANUFACTURER. TRUCK WAS USED ON HIGHWAYS NOT AS A VOCATIONAL TRUCK
Mileage: 300,000
ENGINE WORKING NOT PROPERLY AND SHAKING!!!ITS HAPPENED IN 2019 !!! NOW THE SAME PROBLEM AGAIN!!!
ENGINE WORKING NOT PROPERLY AND SHAKING!!!ITS HAPPENED IN 2019 !!! NOW THE SAME PROBLEM AGAIN!!!
TL* THE CONTACT OWNS A 2018 VOLVO VNL. WHILE DRIVING 57-65 MPH, THE VEHICLE VIBRATED VIOLENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO REPLACED THE DRIVESHAFT TWICE, BUT THE FAILURE CONTINUED. THE VEHICLE WAS TAKEN BACK TO THE MECHANIC WHERE THE CONTACT WAS INFORMED THAT THE VEHICLE WAS OPERATING AS DESIGNED AND WAS SAFE TO DRIVE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE DEALER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 99,421. *TR
Mileage: 99,421
THE STEERING WHEEL ON ALL NEW 2018 VOLVO VNL760 TRACTORS IS PAINFUL TO USE, IMPOSSIBLE TO GRIP PROPERLY, AND HAS A MIS-FUNCTIONING TURN SIGNAL LEVER. PLEASE SEE VIDEO ON YOUTUBE: HTTPS://WWW.YOUTUBE.COM/WATCH?V=8LT4MCUVUCG
Mileage: 625
A PRIOR WRECK HAPPEN SEMI TRUCK TRAILER CROSS MEDIAN AND LAY OVER BLOCKING ALL MY LANES IN THE DARK ON 09/10/18 TIME 0040 HRS RAINING WIPER ON . DID NOT SEE IT TILL FINAL SECONDS ROOF OF SEMI TRAILER FACING ME ON THE GROUND I DROVE THRU THE ROOF OF SEMI TRAILER WITH A LOAD OF CANDY IN IT AIR BAG DID NOT GO OFF , EARLY WARNING DISTANCE SENSOR DID NOT GO OFF EXTREME DAMAGE TO FRONT HOOD , CAB AREA MAYBE WITH THE TRAILER IN A ANGLE HIT AND ROOF FACING ME SENSORS DID NOT GO OFF VEHICLE ???
Mileage: 200,000
A PRIOR WRECK HAPPEN SEMI TRUCK TRAILER CROSS MEDIAN AND LAY OVER BLOCKING ALL MY LANES IN THE DARK ON 09/10/18 TIME 0040 HRS RAINING WIPER ON . DID NOT SEE IT TILL FINAL SECONDS ROOF OF SEMI TRAILER FACING ME ON THE GROUND I DROVE THRU THE ROOF OF SEMI TRAILER WITH A LOAD OF CANDY IN IT AIR BAG DID NOT GO OFF , EARLY WARNING DISTANCE SENSOR DID NOT GO OFF EXTREME DAMAGE TO FRONT HOOD , CAB AREA MAYBE WITH THE TRAILER IN A ANGLE HIT AND ROOF FACING ME SENSORS DID NOT GO OFF VEHICLE ???
Mileage: 200,000
A PRIOR WRECK HAPPEN SEMI TRUCK TRAILER CROSS MEDIAN AND LAY OVER BLOCKING ALL MY LANES IN THE DARK ON 09/10/18 TIME 0040 HRS RAINING WIPER ON . DID NOT SEE IT TILL FINAL SECONDS ROOF OF SEMI TRAILER FACING ME ON THE GROUND I DROVE THRU THE ROOF OF SEMI TRAILER WITH A LOAD OF CANDY IN IT AIR BAG DID NOT GO OFF , EARLY WARNING DISTANCE SENSOR DID NOT GO OFF EXTREME DAMAGE TO FRONT HOOD , CAB AREA MAYBE WITH THE TRAILER IN A ANGLE HIT AND ROOF FACING ME SENSORS DID NOT GO OFF VEHICLE ???
Mileage: 200,000