2000 VOLVO S80

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER

CERTAIN CARDONE MASTER CYLINDERS WITH PART NUMBERS 10-2925, 10-2987, 10-2987MZA, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, AND 11-3156, AND WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAI

SUSPENSION:FRONT:CONTROL ARM:UPPER BALL JOINT

VEHICLE DESCRIPTION: PASSENGER VEHICLES. OVER TIME, THE BALL JOINT BETWEEN THE FRONT WHEEL KING PIN AND THE SUSPENSION LINK ARM, CAN EXPERIENCE INCREASED LOOSENESS.

VEHICLE SPEED CONTROL

ON CERTAIN PASSENGER VEHICLES, A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES, A DIRTY THROTTLE HOUSING, AND/OR INEFFICIENT SOFTWARE CALIBRATION MAY CAUSE A WARNING LAMP TO LIGHT AND THE SUBSEQUENT ONSET OF LIMP HOME MODES.

ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN

ON CERTAIN PASSENGER AND SPORT UTILITY VEHICLES, UNDER CERTAIN OPERATING CONDITIONS, SOME ELECTRIC COOLING FANS MAY OVERHEAT POTENTIALLY CAUSING HEAT DAMAGE AND, IN RARE INSTANCES, A FIRE IN THE ENGINE COMPARTMENT.

EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.

I WANT TO MAKE YOU AWARE OF A VERY SERIOUS CAR ACCIDENT THAT MY MOTHER HAD ON 9-5-18. SHE WAS DRIVING HER 2000 VOLVO S80 WHEN HER CAR BEGAN TO ACCELERATE ON ITS OWN. SHE WAS NOT ABLE TO CONTROL THE CAR. MY MOM HAD HER FOOT ON THE BRAKE BUT THAT DID NOT STOP THE VEHICLE. UNFORTUNATELY, AT THAT POINT THE CAR WAS OUT OF CONTROL HITTING AND BANGING UP ALL THE CARS AROUND IT. THEN THE CAR FINALLY SMASHED INTO ANOTHER CAR STOPPING THE OUT OF CONTROL CAR. MY MOM WAS SERIOUSLY HURT AND TAKEN TO THE HOSP

AS I WAS DRIVING I HEARD A BANG AND SAW SMOKE COMING FROM UNDERNEATH AND BEHIND THE PASSENGER SEAT AND QUICKLY FIRE SPREADING THROUGHOUT THE BACK OF THE VEHICLE. THE REAR WINDOW BLEW OUT. THE CAR WOULD NOT STOP AS I DROVE THE VEHICLE OFF THE STREET. I HAD TO THROW MYSELF OUT OF THE VEHICLE. THE ENTIRE VEHICLE WAS INFLAMED AND EXPLODED. *TR

Mileage: 117,000

AS I WAS DRIVING I HEARD A BANG AND SAW SMOKE COMING FROM UNDERNEATH AND BEHIND THE PASSENGER SEAT AND QUICKLY FIRE SPREADING THROUGHOUT THE BACK OF THE VEHICLE. THE REAR WINDOW BLEW OUT. THE CAR WOULD NOT STOP AS I DROVE THE VEHICLE OFF THE STREET. I HAD TO THROW MYSELF OUT OF THE VEHICLE. THE ENTIRE VEHICLE WAS INFLAMED AND EXPLODED. *TR

Mileage: 117,000

DRIVING ON FREEWAY AT NIGHT, EXPERIENCED A SUDDEN LOSS OF POWER. ENGINE CHECK LIGHT CAME ON. FORTUNATELY COASTED TO A STOP ON AN EXIT RAMP. UPON STOPPING OBSERVED SMOKE COMING THROUGH THE EDGES OF THE HOOD. TURNED OFF THE IGNITION AND EXITED THE CAR. NOTICED A FLAME UNDER THE ENGINE COMPARTMENT. WITHIN ONE MINUTE THE FRONT END OF THE CAR BURST INTO FLAMES AND BURNED IN A BRIGHT YELLOW FIREBALL ESTIMATED TO BE 20 FEET HIGH. IT BURNED UNTIL THE FIRE TRUCKS ARRIVED 20 MINUTES LATER. THE HEA

Mileage: 110,000

DRIVING ON FREEWAY AT NIGHT, EXPERIENCED A SUDDEN LOSS OF POWER. ENGINE CHECK LIGHT CAME ON. FORTUNATELY COASTED TO A STOP ON AN EXIT RAMP. UPON STOPPING OBSERVED SMOKE COMING THROUGH THE EDGES OF THE HOOD. TURNED OFF THE IGNITION AND EXITED THE CAR. NOTICED A FLAME UNDER THE ENGINE COMPARTMENT. WITHIN ONE MINUTE THE FRONT END OF THE CAR BURST INTO FLAMES AND BURNED IN A BRIGHT YELLOW FIREBALL ESTIMATED TO BE 20 FEET HIGH. IT BURNED UNTIL THE FIRE TRUCKS ARRIVED 20 MINUTES LATER. THE HEA

Mileage: 110,000

2000 S80 VOLVO ON HIGHWAY GOING STRAIGHT. 60 MILES AN HR. STEERING WHEEL TURNS RADICALLY TO LEFT. LOOSE CONTROL OF CAR. STEERING WHEEL IS LOCKED. MAC TRUCK DRIVER SAID THAT HE HEARD A LOUD SOUND OUT OF CAR. HE HEARD IT BEFORE HE SAW IT. AFTER BOUNCING OFF TRUCK AND HITTING RAILING. CAR FINALLY STOPS. CAR IS TOTALED. VOLVO BODY OF CAR WAS NOT VERY CRUSHED. I FEARED THAT IF THE MAC TRUCK DID NOT HIT ME. THE VOLVO WOULD HAVE TAKEN MANY LIVES WITH IT. IT WENT THROUGH 4 LANES OF HONKIN

I OWN A 2000 VOLVO S-80 T6, WHICH I HAVE HAD NOTHING BUT PROBLEMS WITH. BEFORE I HAD IT, MY SON OWNED IT AND ALSO HAD PROBLEMS WITH IT. ONE IS THAT THE VEHICLE DOESN'T START, IT STALLS, AND IT SURGES FORWARD OR IN REVERSE. ALL SINCE 2005. JUST LAST MONTH I RAN INTO MY GARAGE DOOR AND SEVERAL TIMES ALMOST WAS INVOLVED IN VEHICLE CRASHES DUE TO IT EITHER SURGING FORWARD OR DYING ON ME. I READ HOW THERE IS A POSSIBLE RECALL ON 2001 MODELS, SO WHY DOES IT NOT INCLUDE 2000 YRS. DOES IT TAKE AN

Mileage: 150,002

TL*THE CONTACT OWNS A 2000 VOLVO S80. WHEN THE CONTACT ARRIVED HOME, SHE NOTICED SMOKE UNDER THE HOOD OF THE VEHICLE. FLAMES WERE PRESENT SOON AFTER. THE FIRE DEPARTMENT ARRIVED AND EXTINGUISHED THE FIRE. EVERYTHING UNDER THE HOOD WAS MELTED. A FIREFIGHTER STATED THAT IT APPEARED TO BE AN ELECTRICAL FIRE. A REPORT WAS FILED. THERE WERE NO INJURIES. THE CONTACT STATED THAT SHE WILL CALL VOLVO AND FILE A CLAIM. THE FAILURE MILEAGE WAS 125,300.

Mileage: 125,300

VOLVO S-80 AIRBAG FAILURE IN A SEVERE CRASH. 2000 VOLVO S-80 INVOLVED IN A SINGLE CAR ACCIDENT (DRIVER WAS THE ONLY OCCUPANT). WENT OFF ROAD AT 55+MPH, SPUN INTO A DITCH HIT THE SIDE OF A MOUNTAIN, TOSSED BACK ACROSS THE ROAD AND LANDED IN THE MEDIAN. TOTALED THE CAR. ALTHOUGH THE SIDE CURTAIN, SIDE IMPACT (IN DRIVER SIDE SEAT) AND PASSENGER FRONT AIRBAGS DEPLOYED, THE MAIN DRIVER AIRBAG IN THE STEERING WHEEL DID NOT DEPLOY. MULTIPLE MINOR INJURIES; UNKNOWN IF ANY WILL TURN OUT TO BE SERIOUS

Mileage: 95,000

TL*THE CONTACT OWNS A 2000 VOLVO S80. WHILE DRIVING AT AN UNKNOWN SPEED, THE CONTACT NOTICED SMOKE AND PULLED THE VEHICLE OFF THE ROAD. HE OPENED THE HOOD AND NOTICED FLAMES. HE WAS UNSUCCESSFUL AT EXTINGUISHING THE FIRE AND CALLED THE FIRE DEPARTMENT, WHO STATED THAT THE COOLING FAN CAUSED AN ELECTRICAL FIRE. THE CONTACT'S MECHANIC INFORMED HIM OF A RECALL REGARDING THE COOLING FAN. THE VIN AND NHTSA CAMPAIGN ID NUMBER WERE UNKNOWN. THE FAILURE AND CURRENT MILEAGES WERE 78,000.

Mileage: 78,000

TL*THE CONTACT OWNS A 2000 VOLVO S80. WHILE DRIVING AT AN UNKNOWN SPEED, THE CONTACT NOTICED SMOKE AND PULLED THE VEHICLE OFF THE ROAD. HE OPENED THE HOOD AND NOTICED FLAMES. HE WAS UNSUCCESSFUL AT EXTINGUISHING THE FIRE AND CALLED THE FIRE DEPARTMENT, WHO STATED THAT THE COOLING FAN CAUSED AN ELECTRICAL FIRE. THE CONTACT'S MECHANIC INFORMED HIM OF A RECALL REGARDING THE COOLING FAN. THE VIN AND NHTSA CAMPAIGN ID NUMBER WERE UNKNOWN. THE FAILURE AND CURRENT MILEAGES WERE 78,000.

Mileage: 78,000

MY WIFE WAS DRIVING THE VEHICLE AND I WAS A PASSENGER. WHEN ATTEMPTING TO OPEN THE SUNROOF AND WHEN IT WAS ABOUT 1/4 OPENED, A STEEL BAR, ABOUT 26 INCHES IN LENGTH CAME OUT OF THE ROOF OPENING AND HIT MY WIFE ON THE RIGHT SIDE OF HER HEAD WHILE SHE WAS DRIVING. THE GLASS DID NOT BREAK ONLY THE METAL BAR THAT WAS GLUED TO THE GLASS CAME LOOSE AND FELL OUT. HAD SHE TURNED HER HEAD IN MY DIRECTION, THE BAR COULD HAVE CAUSED SERIOUS INJURY AND EVEN COULD HAVE HIT ONE OF HER EYES. THIS METAL BAR

Mileage: 124,200

TL*THE CONTACT OWNS A 2000 VOLVO S80. WHILE DRIVING 35 MPH, THE CONTACT NOTICED SMOKE COMING FROM UNDERNEATH THE HOOD OF THE VEHICLE. THE VEHICLE BURST INTO FLAMES. THE INSURANCE AGENCY AND VOLVO INVESTIGATORS DETERMINED THAT THE CAUSE OF FAILURE WAS DUE TO A SHORT IN THE WIRE HARNESS. THE VEHICLE WAS DESTROYED. THE CURRENT AND FAILURE MILEAGES WERE 40,000.

Mileage: 40,000

TL*THE CONTACT OWNS A 2000 VOLVO S80. WHILE DRIVING AT 7 MPH THE STEERING WHEEL LOCKED. THE VEHICLE CRASHED INTO A TREE AND ROLLED OVER. UPON IMPACT, THE AIR BAGS DID NOT DEPLOY. THE ROAD CONDITIONS WERE CLEAR. THE VEHICLE HAS NOT BEEN INSPECTED TO DETERMINE THE CAUSE OF THE FAILURE. THE CURRENT AND FAILURE MILEAGE WERE 111,000. *AK

Mileage: 111,000

TL*THE CONTACT OWNS A 2000 VOLVO S80. WHILE DRIVING AT 7 MPH THE STEERING WHEEL LOCKED. THE VEHICLE CRASHED INTO A TREE AND ROLLED OVER. UPON IMPACT, THE AIR BAGS DID NOT DEPLOY. THE ROAD CONDITIONS WERE CLEAR. THE VEHICLE HAS NOT BEEN INSPECTED TO DETERMINE THE CAUSE OF THE FAILURE. THE CURRENT AND FAILURE MILEAGE WERE 111,000. *AK

Mileage: 111,000

MY 2000 VOLVO S80 T6 ETM THEY SAID THEY WOULD NOT FIX IT UNLESS I BOUGHT A CEM THEY SAID CAR WOULDN'T WORK WITHOUT IT. SO THEY FIXED IT TO A TUNE OF $900.00 FOR CEM SO I CHARGED IT BACK ON MY CREDIT CARD BECAUSE IT'S ALL COVERED ON ETM UPDATE. IN THE MORNING THE CAR STILL REVS MORE I WANT VOLVO TO BUY THIS CAR BACK FROM ME BECAUSE NO ONE INFORMED ME OF THIS PROBLEMS. THEY WOULDN'T GIVE ME OLD CEM I ASKED. *NM

Mileage: 10,000

TL* - THE CONTACT WAS REAR ENDED BY A TRUCK WHILE DRIVING 5 MPH. THE CONTACT STATES THAT IT WAS WINDY AND THAT THERE WERE LIGHT FLURRIES AT THE TIME. THE REAR BACK BUMPER WAS STRUCK AT AN ANGLE ON THE DRIVERS SIDE OF THE VEHICLE. THE CONTACT HAS HAD THE REAR BUMPER REPLACED, AND NOW THE VEHICLE'S LEFT REAR DOOR IS NOT LOCKING AND THE SEAT BELTS NOT LATCHING. THE CONTACT STATED THAT DOOR LOCKS WILL NOT UNLOCK OR LOCK FROM THE MAIN PANEL AND THAT SHE HAS TO LOCK HER CAR MANUALLY. THE CONTACT

Mileage: 95,000

TL* - THE CONTACT WAS REAR ENDED BY A TRUCK WHILE DRIVING 5 MPH. THE CONTACT STATES THAT IT WAS WINDY AND THAT THERE WERE LIGHT FLURRIES AT THE TIME. THE REAR BACK BUMPER WAS STRUCK AT AN ANGLE ON THE DRIVERS SIDE OF THE VEHICLE. THE CONTACT HAS HAD THE REAR BUMPER REPLACED, AND NOW THE VEHICLE'S LEFT REAR DOOR IS NOT LOCKING AND THE SEAT BELTS NOT LATCHING. THE CONTACT STATED THAT DOOR LOCKS WILL NOT UNLOCK OR LOCK FROM THE MAIN PANEL AND THAT SHE HAS TO LOCK HER CAR MANUALLY. THE CONTACT

Mileage: 95,000

TL* - THE CONTACT WAS REAR ENDED BY A TRUCK WHILE DRIVING 5 MPH. THE CONTACT STATES THAT IT WAS WINDY AND THAT THERE WERE LIGHT FLURRIES AT THE TIME. THE REAR BACK BUMPER WAS STRUCK AT AN ANGLE ON THE DRIVERS SIDE OF THE VEHICLE. THE CONTACT HAS HAD THE REAR BUMPER REPLACED, AND NOW THE VEHICLE'S LEFT REAR DOOR IS NOT LOCKING AND THE SEAT BELTS NOT LATCHING. THE CONTACT STATED THAT DOOR LOCKS WILL NOT UNLOCK OR LOCK FROM THE MAIN PANEL AND THAT SHE HAS TO LOCK HER CAR MANUALLY. THE CONTACT

Mileage: 95,000

200 S80 WAS ACCELERATING SPONTANEOUSLY AND LUNGING FORWARD. THE CAR CRASHED INTO A GARAGE WALL WHILE COASTING INTO A PARKING SPACE, AND THE ACCELERATOR WAS NOT DEPRESSED. THE ELECTRONIC THROTTLE MODULE WAS REPLACED. THE VOLVO DEALERSHIP MECHANIC COULD NOT GET THE COMPUTER ERROR CODE, OR APPRECIATE THE SYMPTOMS WHEN HE TEST DROVE THE VEHICLE, AND HAD TO CALL MY LOCAL MECHANIC (WHO IDENTIFIED THE FAULTY ETM) FOR HELP. VOLVO WILL NOW REIMBURSE ALL CUSTOMERS WHO PAID FOR THROTTLE MODULE REPAIR/