2020 TOYOTA RAV4 HYBRID

AIR BAGS:FRONTAL

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2020-2021 Toyota Avalon and 2020 Avalon Hybrid, RAV4, and RAV4 Hybrid vehicles. Breakaway pins within the steering column, designed to absorb energy and reduce injury during a crash, could have been damaged during production, po

STEERING:ELECTRIC POWER ASSIST SYSTEM

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2019-2020 RAV4 and 2020 RAV4 Hybrid vehicles equipped with electric power steering (EPS). Water may enter through the steering gear box cover and cause a loss of electric power steering assist.

AIR BAGS:SENSOR:OCCUPANT CLASSIFICATION

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2020-2021 Avalon, Avalon Hybrid, Corolla, Highlander, Highlander Hybrid, RAV4, RAV4 Hybrid, Lexus ES350, Lexus RX350, Lexus RX450H, 2021 Sienna Hybrid, Lexus ES250, 2020-2022 Camry, Camry Hybrid, and ES300H vehicles. A short cir

SUSPENSION:FRONT:CONTROL ARM:LOWER ARM

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2019-2020 RAV4 and RAV4 Hybrid vehicles. The front lower suspension arms may have cracks, which may result in the suspension arm separating from the front wheel assembly.

ENGINE AND ENGINE COOLING

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2020 Toyota Avalon Hybrid, Camry, Camry Hybrid and Lexus ES300h and 2019-2020 RAV4 and RAV4 Hybrid vehicles equipped with 2.5L 4-Cylinder engines. Porosity in the engine castings may result in cracks than can allow coolant to l

The contact owns a 2020 Toyota Rav4 Hybrid. The contact stated while driving 50 MPH, there was an abnormal knocking sound coming from the suspension. The traction control warning light was illuminated. The contact stated that the sound was intermittent. The vehicle was taken to an unknown dealer, where it was determined that the front lower suspension arms were damaged and needed to be replaced. The vehicle was not repaired due to the cost. The contact stated that while coming to a stop on anoth

Mileage: 120,000

The contact owns a 2020 Toyota Rav4 Hybrid. The contact stated that while driving at various speeds, the vehicle hesitated to maintain automotive power. The messages "PKSB Malfunction - Visit your dealer" and "Pre-Collision System Malfunction - Visit your dealer" were displayed on the instrument panel. The contact stated that the vehicle was repaired at a local dealer for a coolant fault and parts were ordered to repair the wiring harness. The contact stated that while driving at an undisclosed

Mileage: 130,000

The contact owns a 2020 Toyota Rav4 Hybrid. The contact received notification of NHTSA Campaign Number: 23V865000 (AIR BAGS); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2020 Toyota Rav4 Hybrid. The contact received notification of NHTSA Campaign Number: 23V865000 (Air Bags); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not ex

The contact owns a 2020 Toyota Rav4 Hybrid. The contact received notification of NHTSA Campaign Number 23V86500 (Air Bags); however, the part to do the recall repair was not yet available. The local dealer and Northridge Toyota (9550 Nordhoff St., Northridge, CA 91324) were contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had

The contact owns a 2020 Toyota Rav4 Hybrid. The contact stated that on several occasions while attempting to start the vehicle, the vehicle would not start. The vehicle was jumpstarted; however, two days later the failure recurred. The vehicle was taken to a dealer twice where it was diagnosed and determined that the battery needed to be replaced. The vehicle was repaired; however, the failure reoccurred after 18 months. The vehicle was then taken to the dealer where the vehicle remained. The ma

Mileage: 33,846

The contact owns a 2020 Toyota Rav4 Hybrid. The contact received notification of NHTSA Campaign Number: 23V865000 (Air Bags); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2020 Toyota Rav4 Hybrid. The contact stated that while the vehicle was turned off on several occasions, the liftgate button was depressed and the liftgate was partially raised before freezing. The vehicle was taken to a dealer where it was diagnosed that the driver’s side liftgate hinge had cracked and snapped, causing the liftgate to become inoperable. The vehicle was repaired. On another occasion, the liftgate failed to close fully and failed to operate as intended. The ve

The contact owns a 2020 Toyota Rav4 Hybrid. The contact stated that while driving at an undisclosed speed, he became aware that the driver's side sideview mirror was vibrating excessively, distorting the image seen. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage

Mileage: 53,000

The contact owns a 2020 Toyota Rav4 Hybrid. The contact stated while using the A/C, there was an abnormally foul odor coming from the vents. The vehicle was taken to a dealer where a mechanic discovered mice had entered the vehicle through an opening in the engine and that droppings were found in the air filter housing. The air filter was replaced, and the contact was advised to use Lysol spray to spray the air cabin. Upon investigation, the contact's husband discovered that the wiring was made

Mileage: 23,000

The contact owns a 2020 Toyota Rav4 Hybrid. The contact stated while using the A/C, there was an abnormally foul odor coming from the vents. The vehicle was taken to a dealer where a mechanic discovered mice had entered the vehicle through an opening in the engine and that droppings were found in the air filter housing. The air filter was replaced, and the contact was advised to use Lysol spray to spray the air cabin. Upon investigation, the contact's husband discovered that the wiring was made

Mileage: 23,000

The contact owns a 2020 Toyota Rav4 Hybrid. The contact stated while his mother was driving 45 MPH, the electronic throttle control system warning light illuminated. The vehicle was taken to the dealer to be diagnosed. The contact was informed that the MGR (Motor Generator Rear) system needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and notified of the failure but offered no assistance. The contact was also informed that the vehicle was not covered under warra

Mileage: 53,000

The contact owns a 2020 Toyota Rav4 Hybrid. The contact stated while his mother was driving 45 MPH, the electronic throttle control system warning light illuminated. The vehicle was taken to the dealer to be diagnosed. The contact was informed that the MGR (Motor Generator Rear) system needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and notified of the failure but offered no assistance. The contact was also informed that the vehicle was not covered under warra

Mileage: 53,000

FUEL TANK WILL FILL UP COMPLETELY

TL* THE CONTACT OWNS A 2020 TOYOTA RAV4 HYBRID. THE CONTACT STATED THAT THE STEERING WAS FIRM AT VEHICLE START-UP. THE CONTACT STATED THAT THE STEERING WHEEL BECAME DIFFICULT TO TURN. THE CONTACT STATED THAT THE SERVICE STEERING WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TOWED TO CENTRAL CITY TOYOTA LOCATED 4800 CHESTNUT ST, PHILADELPHIA, PA 19139, (215) 476-1200, TO BE DIAGNOSED. THE MECHANIC WAS UNABLE TO PROVIDE A CAUSE FOR THE FAILURE. THE CONTACT WAS INFORMED THAT THE BATTERY VOLTAGE WA