2004 TOYOTA RAV4

AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2016 4Runner, 2003-2006 Tundra, 2003-2013 Corolla, 2009-2010 Corolla Matrix, 2004-2005 RAV4, 2002-2007 Sequoia, 2011-2013 Sienna, 2008-2012 Scion xB, 2008-2009 Lexus IS-F, 2007-2012 Yaris and Lexus ES350, 2010-2017 Lexus GX4

AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2004-2005 Toyota RAV4 vehicles manufactured May 13, 2003, to October 25, 2005. The affected vehicles are equipped with a dual-stage driver frontal air bag that may be susceptible to moisture intrusion which, over time

TL* THE CONTACT OWNS A 2004 TOYOTA RAV4. WHILE REVERSING THE VEHICLE, THE ACCELERATOR PEDAL BECAME STUCK. THE BRAKE PEDAL FAILED TO SLOW DOWN THE VEHICLE AND THE SPEED EXCEEDED 55 MPH. THE CONTACT'S VEHICLE CRASHED INTO ANOTHER VEHICLE, WHICH ENDED UP DESTROYED. A POLICE REPORT WAS FILED. THE CONTACT WAS NOT INJURED. THE DEALER (WELLESLEY TOYOTA, 234 WORCESTER ST, WELLESLEY, MA 02481, (888) 577-6342) WAS NOTIFIED OF THE FAILURE AND THE SERVICE CENTER MANAGER INDICATED THAT THERE WAS NO DETERMINE

Mileage: 55,000

MY SON AND I WERE ON WAY TO PEYTON MANNING CHILDREN'S HOSPITAL IN MY 2004 TOYOTA RAV4 WHEN THE DRIVER IN FRONT OF ME ABRUPTLY STOPPED, WHICH MADE ME ABRUPTLY STOP, HOWEVER, THE DRIVER BEHIND ME WAS NOT PAYING ATTENTION AND REAR ENDED ME AS I WAS COMPLETELY STOPPED AND HE WAS GOING ABOUT 30 MPH. THIS OCCURRED ON THE PASSENGER BACK OF THE VEHICLE CAUSING ALMOST $4,000 WORTH OF DAMAGE, HOWEVER, MY SON NOR MY SEAT BELTS LOCKED INTO PLACE, THEREFORE, HE SUSTAINED A SIGNIFICANT CONCUSSION, WHIP LASH,

Mileage: 153,000

I WAS PULLING INTO A PARKING SPOT AT LESS THAN 10 MPH WHEN THE ENGINE REVVED LOUDLY, LURCHED FORWARD, JUMPED THE CURB AND CONTINUED UP A SLOPE. I WAS UNABLE TO STOP THE CAR. I WAS ABLE TO TURN THE WHEEL TO AVOID A HEAD-ON COLLISION WITH A BUILDING, AND INSTEAD HIT THE BUILDING ON AN ANGLE ON THE LEFT FRONT SIDE. THE CAR STOPPED ONLY AFTER HITTING THE BUILDING. THIS IS THE THIRD INSTANCE OF "UNINTENDED ACCELERATION" I HAVE EXPERIENCED WITH THIS VEHICLE. THIS WAS THE MOST SERIOUS EPISODE. TH

Mileage: 60,000

TL* THE CONTACT OWNED A 2004 TOYOTA RAV 4. WHILE DRIVING AT 45 MPH, THE CONTACT VEERED INTO THE RIGHT LANE. AS A RESULT, THE CONTACT CRASHED INTO THE REAR OF ANOTHER VEHICLE AND THE AIR BAGS FAILED TO DEPLOY. THE CONTACT SUSTAINED BRUISES THAT REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED FROM THE CRASH SCENE AND WAS DEEMED DESTROYED. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V284000 (AIR BAGS). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILU

Mileage: 108,000

TL* THE CONTACT OWNS A 2004 TOYOTA RAV4. THE CONTACT STATED THAT AFTER MAKING A LEFT TURN AT APPROXIMATELY 15 MPH, THE FRONT PASSENGER AND DRIVER SIDE AIR BAGS DEPLOYED INADVERTENTLY WITHOUT WARNING. AS A RESULT, THE CONTACT LOST CONTROL OF THE VEHICLE AND CRASHED INTO THE CURB CAUSING ALL FOUR TIRES TO BLOW. A POLICE REPORT WAS NOT FILED AND THERE WERE NO INJURIES REPORTED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTI

Mileage: 330,000

MY MOTHER WAS INVOLVED IN A SIDE IMPACT CRASH (PASSENGERS SIDE) IN 2014. HER CAR WAS TOTALED AS THE OTHER CAR ESSENTIALLY SPEARED HERS CAVING IN THE RIGHT SIDE. SHE WAS WEARING SEATBELT AND THE AIRBAG DEPLOYED. MOM SURVIVED WITH NO INTERNAL INJURIES. HOWEVER SHE WAS LEFT WITH SEVERE LACERATIONS TO THE SCALP, FACE AND HEMATOMA TO THE HEAD WHICH NEEDED SURGERY. I SUSPECT THIS INJURY WAS FROM THE AIRBAG DEPLOYING VIOLENTLY. MY HUSBAND WHO IS A RETIRED FIREFIGHTER/MEDIC INSPECTED THE CAR

Mileage: 22,000

I WAS STOPPED AT A RED LIGHT WITH ~1 CAR LENGTH BETWEEN ME AND ONE CAR IN FRONT OF ME. WHEN THE LIGHT TURNED GREEN AND THE CAR AHEAD BEGAN TO MOVE, I TOOK MY FOOT OFF THE BRAKE AND MOVED IT TO THE ACCELERATOR AS USUAL. AT THAT POINT, MY CAR RAPIDLY ACCELERATED OUT OF CONTROL AND HIT THE CAR IN FRONT. MY BRAKES WOULDN'T ENGAGE AND MY CAR CONTINUED TO ACCELERATE RAPIDLY. I HAD TO SWERVE AROUND THE CAR I HIT WHILE MY CAR CONTINUED AT HIGH SPEED THROUGH TWO STOP SIGNS IN A RESIDENTIAL NEIGHBORHOOD.

Mileage: 45,309

I WAS STOPPED AT A RED LIGHT WITH ~1 CAR LENGTH BETWEEN ME AND ONE CAR IN FRONT OF ME. WHEN THE LIGHT TURNED GREEN AND THE CAR AHEAD BEGAN TO MOVE, I TOOK MY FOOT OFF THE BRAKE AND MOVED IT TO THE ACCELERATOR AS USUAL. AT THAT POINT, MY CAR RAPIDLY ACCELERATED OUT OF CONTROL AND HIT THE CAR IN FRONT. MY BRAKES WOULDN'T ENGAGE AND MY CAR CONTINUED TO ACCELERATE RAPIDLY. I HAD TO SWERVE AROUND THE CAR I HIT WHILE MY CAR CONTINUED AT HIGH SPEED THROUGH TWO STOP SIGNS IN A RESIDENTIAL NEIGHBORHOOD.

Mileage: 45,309

I ENTERED MY CAR IN THE HOME GARAGE WHILE COASTING AND THE CAR SUDDENLY ACCELERATED AS I APPROACHED ABOUT 5 FEET WITHIN MY PARKING SPOT. AFTER THE CAR SUDDENLY ACCELERATED, IT WAS A MATTER OF SECONDS BEFORE THE CAR CRASHED INTO A FLOOR CABINET AND REFRIGERATOR THAT RESTS AGAINST OUR GARAGE WALL STOPPING THE CAR'S FORWARD MOVEMENT AND ALLOWING ME PUT THE CAR IN THE DRIVE GEAR AND TURN OFF THE ENGINE. THE AIR BAGS DID NOT DEPLOY AND FORTUNATELY I WAS NOT INJURED. THE CRASH CAUSED EXTENSIVE DAMAG

Mileage: 80,764

I ENTERED MY CAR IN THE HOME GARAGE WHILE COASTING AND THE CAR SUDDENLY ACCELERATED AS I APPROACHED ABOUT 5 FEET WITHIN MY PARKING SPOT. AFTER THE CAR SUDDENLY ACCELERATED, IT WAS A MATTER OF SECONDS BEFORE THE CAR CRASHED INTO A FLOOR CABINET AND REFRIGERATOR THAT RESTS AGAINST OUR GARAGE WALL STOPPING THE CAR'S FORWARD MOVEMENT AND ALLOWING ME PUT THE CAR IN THE DRIVE GEAR AND TURN OFF THE ENGINE. THE AIR BAGS DID NOT DEPLOY AND FORTUNATELY I WAS NOT INJURED. THE CRASH CAUSED EXTENSIVE DAMAG

Mileage: 80,764

I WAS STARTING TO MAKE A K-TURN IN A PARKING LOT. I PUT ON THE BRAKES TO SHIFT INTO REVERSE. I MOVED BACK IN REVERSE A LITTLE BIT. THEN I STOPPED THE CAR AND PUT IT IN DRIVE, WHEN THE CAR SUDDENLY LURCHED FORWARD OUT OF MY CONTROL CRASHING INTO A GARBAGE DUMPSTER, FRIGHTENING ME AND DAMAGING MY VEHICLE SEVERELY. I AM CERTAIN I DID NOT GIVE THE CAR ANY GAS TO MAKE IT GO FORWARD AND CAUSE THAT ACCIDENT. I FEEL VERY FORTUNATE THAT I SUFFERED ONLY MINOR ACHES AND PAINS AS I WAS 75 AT THE TIME. I STI

Mileage: 1,000

I WAS STARTING TO MAKE A K-TURN IN A PARKING LOT. I PUT ON THE BRAKES TO SHIFT INTO REVERSE. I MOVED BACK IN REVERSE A LITTLE BIT. THEN I STOPPED THE CAR AND PUT IT IN DRIVE, WHEN THE CAR SUDDENLY LURCHED FORWARD OUT OF MY CONTROL CRASHING INTO A GARBAGE DUMPSTER, FRIGHTENING ME AND DAMAGING MY VEHICLE SEVERELY. I AM CERTAIN I DID NOT GIVE THE CAR ANY GAS TO MAKE IT GO FORWARD AND CAUSE THAT ACCIDENT. I FEEL VERY FORTUNATE THAT I SUFFERED ONLY MINOR ACHES AND PAINS AS I WAS 75 AT THE TIME. I STI

Mileage: 1,000

TL* THE CONTACT OWNS A 2004 TOYOTA RAV4. THE CONTACT WAS DRIVING APPROXIMATELY 15 MPH AND ATTEMPTING A LEFT TURN WHEN ANOTHER VEHICLE CRASHED INTO THE FRONT PASSENGER SIDE DOOR OF THE CONTACT'S VEHICLE. THE VEHICLE SLID FORWARD AND PROCEEDED TO CRASH OVER A CURB AND INTO A POLE. THE SIDE CURTAIN AIR BAGS FAILED TO DEPLOY. IMMEDIATELY AFTER THE CRASH, SMOKE BEGAN EMITTING FROM THE ENGINE COMPARTMENT. THE DRIVER WAS ABLE TO EXIT THE VEHICLE AND NOTICED FLAMES COMING FROM UNDER THE HOOD. THE FIRE D

Mileage: 34,000

TL* THE CONTACT OWNS A 2004 TOYOTA RAV4. THE CONTACT WAS DRIVING APPROXIMATELY 15 MPH AND ATTEMPTING A LEFT TURN WHEN ANOTHER VEHICLE CRASHED INTO THE FRONT PASSENGER SIDE DOOR OF THE CONTACT'S VEHICLE. THE VEHICLE SLID FORWARD AND PROCEEDED TO CRASH OVER A CURB AND INTO A POLE. THE SIDE CURTAIN AIR BAGS FAILED TO DEPLOY. IMMEDIATELY AFTER THE CRASH, SMOKE BEGAN EMITTING FROM THE ENGINE COMPARTMENT. THE DRIVER WAS ABLE TO EXIT THE VEHICLE AND NOTICED FLAMES COMING FROM UNDER THE HOOD. THE FIRE D

Mileage: 34,000

TL* THE CONTACT OWNS A 2004 TOYOTA RAV4. THE CONTACT WAS DRIVING 50 MPH WHEN ALL OF THE WARNING LIGHTS ILLUMINATED AND THE ENGINE BEGAN TO SMOKE. THE VEHICLE WAS THEN TOWED TO THE DEALER AND THEY ADVISED HER THAT THE BOLTS WERE DETERIORATED CAUSING THE GASKET TO OVERHEAT AND THE ENTIRE ENGINE WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND THEY OFFERED TO COVER FIFTY PERCENT OF THE REPAIR COSTS. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 90,00

Mileage: 90,000

TL* THE CONTACT OWNS A 2004 TOYOTA RAV4. THE CONTACT STARTED THE VEHICLE AND AS HE SHIFTED INTO REVERSE, A RAPID ACCELERATION OCCURRED CAUSING THE VEHICLE TO CRASH INTO A BUILDING. THE CONTACT SUSTAINED MINOR INJURIES TO THE NECK. A POLICE REPORT WAS FILED. THE VEHICLE WAS DESTROYED AND TOWED TO A COLLISION FACILITY. THE FAILURE MILEAGE WAS 62,000. UPDATED 04/07/11*LJ

Mileage: 62,000

AVOIDING DEER, HIT EMBANKMENT AND CAR ROLLED ONTO PASSENGER SIDE. NO AIRBAGS DEPLOYED. CAR EQUIPPED WITH FRONT AND SIDE AIRBAGS. *TR

Mileage: 116,000

AVOIDING DEER, HIT EMBANKMENT AND CAR ROLLED ONTO PASSENGER SIDE. NO AIRBAGS DEPLOYED. CAR EQUIPPED WITH FRONT AND SIDE AIRBAGS. *TR

Mileage: 116,000

2004 TOYOTA RAV4 L - DRIVING ABOUT 25 MPH, NO DASH WARNING LIGHTS ON, SMOKE STARTED COMING INTO CABIN, WITHIN LESS THAN A MINUTE FIRE SHOOTING OUT FROM UNDER HOOD. TOTALLY ENGULFED IN FLAMES IN LESS THAN 3 MINUTES. REGULAR SERVICE DONE AT TOYOTA DEALER. *TR

Mileage: 56,000

2004 RAV4. ACCELERATOR HAS BECOME ERRATIC IN THE LAST 3 MONTHS. CAR WILL LEAP AHEAD WITH VIRTUALLY NO PRESSURE ON PEDAL. ONLY DOES IT OCCASIONALLY. PEDAL IS MOUNTED QUITE HIGH, ABOVE THE BRAKE PEDAL, AND CANNOT CONTACT FLOOR MATS. WHILE PULLING INTO A RIGHT ANGLE PARKING SPOT AT LOW SPEED AND WITH FOOT ON BRAKE, VEHICLE SUDDENLY SURGED AHEAD. I WAS ONLY 5 FEET FROM A BRICK WALL AND COULD NOT RESPOND QUICKLY ENOUGH TO BRAKE THE VEHICLE. IMPACT WITH WALL PLASTER (ABOUT 1 FOOT WIDE) CRUSHED