2000 PLYMOUTH GRAND VOYAGER

FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM

VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.

VISIBILITY:GLASS, SIDE/REAR

CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS LTD AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., IDENTIFIED AS DOT-430, AND SOLD FOR USE ON CERTAIN DOMESTIC AND FOREIGN VEHICLES MAY NOT BREAK INTO SMALL PIECES AS EXPECTED OF TEMPERED GLASS AND FAILS TO CONFORM TO FEDER

AIR BAGS

ON CERTAIN MINIVANS, THE DRIVER'S AIR BAG MAY BECOME DISABLED DUE TO A FAILURE OF THE CLOCKSPRING, WHICH IS LOCATED IN THE HUB OF THE STEERING WHEEL.

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

CERTAIN AIRTEX FUEL PUMP MODULES, P/NOS. E7089M, E7094M, E7113M, AND E7129M, MANUFACTURED BETWEEN JUNE 1 AND SEPTEMBER 24, 2006. THESE FUEL PUMP MODULES WERE SOLD AS AFTERMARKET FOR USE IN CERTAIN DAIMLERCHRYSLER VEHICLES LISTED ABOVE. SILICONE MATERIAL USED IN MANUFACTURE OF THE FLAPPER VALVE WAS

WHILE DRIVING DOWN A STEEP HILL THE BRAKES WENT TO THE FLOOR AND THE RED "NO BRAKE" LIGHT CAME ON. I WAS GOING AROUND 30 MILES AN HOUR AND LUCKILY WAS IN THE COUNTRY. I DROVE INTO A FARMERS FIELD AND PUT ON THE EMERGENCY BRAKE. THE DEALERSHIP REPLACED THE BRAKE EQUIPMENT INCLUDING THE MASTER CYLINDER EVEN THOUGH NOTHING WAS SHOWING ON THEIR COMPUTER. A FEW DAYS LATER I WAS DRIVING HOME FROM WORK AND CAME TO A STOP SIGN, PUT ON BRAKES AND THEY WENT TO THE FLOOR AGAIN. I HIT THE VEHICLE IN F

Mileage: 60,000

THE VEHICLE RAN OFF THE ROAD WHILE DRIVING 35-45 MPH INTO A FENCE AND THEN INTO A WOODEN POLE AND NEITHER FRONTAL AIR BAG DEPLOYED. *JB THE CONSUMER RECEIVED A HEAD INJURY WITH 6 STAPLES AND OTHER SMALL CUT TO THE HEAD AND FACE. CONSUMER ALSO CUT RIGHT HAND IN THE ACCIDENT. *TC

Mileage: 71,000

VAN CAUGHT FIRE IN THE ENGINE, ON THE DRIVER'S SIDE, VERY LIKELY AS A RESULT OF O RING FAILURE AT FUEL RAILS-NOT PART OF RECALL ISSUED ON SEPTEMBER 9, 1999. *JB

Mileage: 69,000

MY 2000 CHRYSLER GRAND VOYAGER'S ENGINE BURST INTO FLAMES AND ALMOST THE WHOLE FRONT END OF MY CAR, INCLUDING MY DASH BOARD AND PART OF MY FRONT SEATS WERE BURNED UP. THE WINDSHIELD AND THE WINDOWS ON THE PASSENGER AND DRIVER'S SIDE IN THE FRONT BLEW OUT. I SUFFERED FROM SMOKE INHALATION AND DID END UP GOING TO THE EMERGENCY ROOM. I ALSO HAVE PULLED SOMETHING IN MY BACK AND ARMS THAT HAS MADE MY ARMS FROM THE ELBOWS TO THE HANDS GO PAINFULLY NUMB AND PRICKLY. IN ADDITION, I SEEMED TO HAVE CA

Mileage: 69,000

MY DAUGHTERS (AGES 5 AND 2) WERE SITTING IN THE FRONT SEAT OF MY VAN AND HIT THE GEAR SHIFT AND KNOCKED IT INTO GEAR AND THE VAN ROLLED INTO MY BROTHER-IN LAWS TRUCK ALMOST PINNING ME BETWEEN THE TWO VEHICLES.*JB

Mileage: 54,000

VEHICLE CAUGHT FIRE WHILE PARKED, CLAIM # 40-2413-995 . NLM

CONSUMER STATES VEHICLE CAUGHT ON FIRE WHILE IT WAS PARKED, INSURANCE SAID THE CAUSE OF LOSS IS UNKNOWN BUT THE ONLY THING THEY KNOW IS THAT IT WAS AN ELECTRICAL FIRE (CLAIM # 40-2413-995). *YD

CONSUMER STATES VEHICLE CAUGHT ON FIRE WHILE IT WAS PARKED, INSURANCE SAID THE CAUSE OF LOSS IS UNKNOWN BUT THE ONLY THING THEY KNOW IS THAT IT WAS AN ELECTRICAL FIRE (CLAIM # 40-2413-995). *YD

VEHICLE CAUGHT FIRE WHILE PARKED, CLAIM # 40-2413-995 . NLM

CONSUMER WAS SITTING IN LINE TO PAY HER TOW FEE. AFTERWARDS SHE STOPPED IN LINE TO LET ANOTHER VEHICLE GET IN FRONT OF HER. AND WITHOUT PRIOR WARNING, A TRACTOR TRAILER HIT CONSUMER'S VEHICLE. UPON IMPACT, DRIVER'S SIDE SEAT BROKE AND TWISTED AND THEW HER BETWEEN PASSENGER'S SEAT. DEALERSHIP WAS AWARE OF PROBLEM.*AK

NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK

CAR WAS PARKED FOR 6 HOURS AND AN ELECTRICAL FIRE STARTED. FIRE WAS CAUSED BY A FUSE RELATED TO STOP LAMPS/ AIRBAGS AND MEMORY FUSE.*AK

I WAS INVOLVED IN AN ACCIDENT ON THE DATE GIVEN. THE OTHER PARTY INVOLVED PULLED OUT IN FRONT OF ME. I HIT HER AT ABOUT 45 MPH. THE MAIN IMPACT WAS AROUND THE LOCATION OF MY LEFT HEADLIGHT, DRIVER'S SIDE AND FRONT. MY AIRBAG DID NOT DEPLOY, MY SEATBELT DID NOT LOCK AND RESTRAIN ME AND MY BACK SEAT COLLAPSED UPON IMPACT. CHRYSLER HAS SENT AN ENGINEER TO LOOK AT THE VAN AND I STILL HAVE NOT HEARD BACK FROM THEM. THE ESTIMATE IS STILL NOT COMPLETE BY STAN'S AUTO BODY AND THE TOTAL IS ALREADY

I WAS INVOLVED IN AN ACCIDENT ON THE DATE GIVEN. THE OTHER PARTY INVOLVED PULLED OUT IN FRONT OF ME. I HIT HER AT ABOUT 45 MPH. THE MAIN IMPACT WAS AROUND THE LOCATION OF MY LEFT HEADLIGHT, DRIVER'S SIDE AND FRONT. MY AIRBAG DID NOT DEPLOY, MY SEATBELT DID NOT LOCK AND RESTRAIN ME AND MY BACK SEAT COLLAPSED UPON IMPACT. CHRYSLER HAS SENT AN ENGINEER TO LOOK AT THE VAN AND I STILL HAVE NOT HEARD BACK FROM THEM. THE ESTIMATE IS STILL NOT COMPLETE BY STAN'S AUTO BODY AND THE TOTAL IS ALREADY

VEHICLE WAS TRAVELING AT APPROXIMATELY 5 MPH WHEN LOSS OF STEERING OCCURRED. CONSUMER CRASHED INTO ANOTHER VEHICLE. UPON EXAMINATION, FRONT LOWER CONTROL ARM HAD CRACKED. A PRIVATE MECHANIC HAS EXAMINED VEHICLE, AND HAS YET TO DETERMINE A CAUSE FOR DEFECT. PLEASE PROVIDE ANY ADDITIONAL INFORMATION/ATTACHMENTS. *AK

WHILE SLOWING WITH TRAFFIC ANOTHER VEHICLE CAME FROM LEFT HAND LANE AT ABOUT 45 MPH AND HIT CONSUMER'S VEHICLE ON THE REAR. THEN, CONSUMER HIT CAR IN FRONT OF HIM. UPON IMPACT, DRIVER'S SEAT BROKE AND FELL BACKWARDS. *AK THE PASSENGER SEAT BROKE TOO. THE AIR BAGS FAILED TO DEPLOY. *YH

WHILE SLOWING WITH TRAFFIC ANOTHER VEHICLE CAME FROM LEFT HAND LANE AT ABOUT 45 MPH AND HIT CONSUMER'S VEHICLE ON THE REAR. THEN, CONSUMER HIT CAR IN FRONT OF HIM. UPON IMPACT, DRIVER'S SEAT BROKE AND FELL BACKWARDS. *AK THE PASSENGER SEAT BROKE TOO. THE AIR BAGS FAILED TO DEPLOY. *YH

AFTER PARKING VEHICLE AND RETURNING IN MORNING THERE WAS EVIDENCE THAT VAN CAUGHT ON FIRE AND BURNED DASHBOARD. COMPLETE DASHBOARD WAS MELTED, INCLUDING VENTS.*AK

DROVE ABOUT THREE MILES AND PARKED VEHICLE. THEN, WAS INFORMED THAT VEHICLE WAS ON FIRE. ACCORDING TO FIRE DEPARTMENT FIRE HAD STARTED BECAUSE AN ELECTRICAL SHORT. THE VEHICLE WAS TOTALED AND MANUFACTURER IS TO REPLACE IT *AK

WHILE VEHICLE WAS PARKED WITH GEAR SHIFT IN PARK AND ENGINE STILL RUNNING, CONSUMER GOT OUT OF VEHICLE AND CLOSED THE DOOR. SUDDENLY VEHICLE TOOK OFF AND RAN INTO ANOTHER VEHICLE WHILE GEAR SHIFT STILL REMAINED IN PARK. DEALER NOTIFIED. *AK