2019 MERCEDES-BENZ SPRINTER (VS30)

STEERING:GEAR BOX:SHAFT SECTOR

Daimler Vans USA, LLC (Daimler Vans) is recalling certain 2019 Mercedes-Benz Sprinter VS30 vehicles. The steering shaft that connects to the steering gear may disconnect without warning.

SUSPENSION:REAR

Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Mercedes Benz Sprinter vehicles. The chassis may be missing the additional stabilization required for its cargo capacity. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 126, "Elect

SUSPENSION:REAR:SPRINGS:LEAF SPRING ASSEMBLY:LEAF

Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Mercedes Benz Sprinter and Freightliner Sprinter vehicles. The incorrect leaf spring shims may have been installed between the rear axle and the leaf springs possibly affecting the vehicle's handling. As such, these vehicles fail to comply wi

EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Freightliner Sprinter and Mercedes-Benz Sprinter vehicles. The Operator's Manual may not contain the correct information about how the automatic parking function ("Auto-P") operates.

SERVICE BRAKES, AIR:SUPPLY:HOSES, LINES/PIPING, AND FITTINGS

Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Freightliner Sprinter and Mercedes-Benz Sprinter vehicles. The rear part of the fender liner on the front axle may contact and chafe the brake hose, possibly resulting in a loss of brake fluid.

EXTERIOR LIGHTING:FOG LIGHTS

Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Mercedes-Benz Sprinter VS30 vehicles equipped with LED rear fog lights. The lights may not illuminate, despite the rear fog light switch being turned on.

EQUIPMENT

Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles. The lashing rails on the side walls may not have been properly installed, possibly resulting in the lashing rails detaching.

ELECTRONIC STABILITY CONTROL (ESC):CONTROL MODULE:SOFTWARE

Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Mercedes-Benz Sprinter vehicles equipped with the camper upfit option. The Electronic Stability Control (ESP) software was not updated for vehicles with a higher center of gravity.

VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:FAN/MOTOR

Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2020 Mercedes-Benz Sprinter VS30 and Freightliner Sprinter VS30 vehicles. The heating, ventilation, and air conditioning (HVAC) blower motor circuit may be inadequate, which can allow the wiring harness to overheat.

EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Mercedes Benz Sprinter vehicles. These vehicles may have been delivered with a version of the printed and digital operator's manual that may be inaccurate and/or incomplete.

STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS

Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2020 Mercedes Benz Sprinter and Freightliner Sprinter vehicles. The hydraulic power steering return line hoses may detach and cause hydraulic fluid to leak.

EQUIPMENT:OTHER:LABELS

Daimler Vans USA, LLC (DVUSA) is recalling one 2019 Mercedes Benz Sprinter vehicle. The VIN number listed on the vehicle's dash board, certification label, and body-in-white do not match. As such, this vehicle fails to comply with the requirements of Federal Motor Vehicle Safety Standard number 56

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles. The affected Sprinter vehicles from platform 907 (VS30) might have an open port on the fuel delivery module (fuel pump).

AIR BAGS:SIDE/WINDOW

Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Mercedes-Benz and Freightliner Spinter vans (platform 970 (VS30)), equipped with swivel seats. The wiring harnesses for the front seats may have been routed incorrectly and could become jammed and damaged in the swivel seat frames.

At approximately 104 miles into a recent trip in our RV, while traveling at highway speed under cruise control, we noticed a strange odor. Almost at the same moment we immediately lost engine and braking power. The check engine light came on. We then noticed smoke coming from the engine compartment and noxious fumes had begun to enter the cabin area. After pulling to the side of the highway by use of the emergency brake, we were able to exit the vehicle. Flames could be seen coming from the engi

At approximately 104 miles into a recent trip in our RV, while traveling at highway speed under cruise control, we noticed a strange odor. Almost at the same moment we immediately lost engine and braking power. The check engine light came on. We then noticed smoke coming from the engine compartment and noxious fumes had begun to enter the cabin area. After pulling to the side of the highway by use of the emergency brake, we were able to exit the vehicle. Flames could be seen coming from the engi

At approximately 104 miles into a recent trip in our RV, while traveling at highway speed under cruise control, we noticed a strange odor. Almost at the same moment we immediately lost engine and braking power. The check engine light came on. We then noticed smoke coming from the engine compartment and noxious fumes had begun to enter the cabin area. After pulling to the side of the highway by use of the emergency brake, we were able to exit the vehicle. Flames could be seen coming from the engi

The contact owns a 2019 Mercedes-Benz Sprinter 3500. The contact stated that while seated in the swivel chair inside the vehicle, she turned the swivel chair around to watch the television and several unknown warning lights started flashing on and off and the vehicle would not start. The contact stated that an independent mechanic was contacted and arrived at the residence to service the vehicle. An unknown repair was performed and the vehicle was able to be started. The vehicle was taken to the

Mileage: 15,000

The contact owns a 2020 Tiffin Wayfarer Motorhome built on a 2019 Mercedes-Benz Sprinter 3500/4500 chassis. The contact stated that while driving approximately 55-65 MPH, the water tank fell onto the exhaust system. The contact received notification of NHTSA campaign numbers: 21V610000 (Trailer Hitches) and 21V753000 (Equipment). The contact called the local dealer who stated additional hours were needed to complete the repairs. The vehicle was not diagnosed or repaired. The contact stated that

Mileage: 15,000

The contact owns a 2020 Tiffin Wayfarer Motorhome built on a 2019 Mercedes-Benz Sprinter 3500/4500 chassis. The contact stated that while driving approximately 55-65 MPH, the water tank fell onto the exhaust system. The contact received notification of NHTSA campaign numbers: 21V610000 (Trailer Hitches) and 21V753000 (Equipment). The contact called the local dealer who stated additional hours were needed to complete the repairs. The vehicle was not diagnosed or repaired. The contact stated that

Mileage: 15,000

The contact owns a 2020 Tiffin Wayfarer Motorhome built on a 2019 Mercedes-Benz Sprinter 3500/4500 chassis. The contact stated that while driving approximately 55-65 MPH, the water tank fell onto the exhaust system. The contact received notification of NHTSA campaign numbers: 21V610000 (Trailer Hitches) and 21V753000 (Equipment). The contact called the local dealer who stated additional hours were needed to complete the repairs. The vehicle was not diagnosed or repaired. The contact stated that

Mileage: 15,000

ACCIDENT ON 10/15/2020, UNOCCUPIED VEHICLE ROLLED FROM A PARKED POSITION DOWN A HILL AND STRUCK A HOUSE. THE VEHICLE IS DESIGNED TO HAVE THE TRANSMISSION AUTOMATICALLY SHIFT TO PARK WHEN THE DRIVER'S DOOR IS OPEN, AND THIS SYSTEM WAS FUNCTIONAL AT THE TIME OF THE INCIDENT. DISENGAGEMENT OF THE PARKING PAWL WAS THE CAUSE OF THE EVENT.

Mileage: 21,130