2004 MAZDA RX-8

AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE

Mazda North American Operations (Mazda) is recalling certain 2003-2008 Mazda6, 2004-2005 MPV, 2004 RX-8, and 2006-2007 Mazdaspeed6 vehicles. These vehicles had their passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may e

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

Mazda North America Operations (Mazda) is recalling certain model year 2004-2008 RX-8 vehicles manufactured April 10, 2003, to February 18, 2008. The affected vehicles have fuel pump sealing rings that may deteriorate due to exposure to heat from the engine or exhaust pipe.

AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE

Mazda North American Operations (Mazda) is recalling certain model year 2003-2008 Mazda6, 2004-2008 RX-8, and 2006-2007 Mazdaspeed6 vehicles. The affected vehicles are equipped with a dual-stage driver frontal air bag that may be susceptible to moisture intrusion and other factors, including manufa

SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT

ON CERTAIN PASSENGER VEHICLES, DUE TO IMPROPER FORGING OF THE LOWER CONTROL ARM, CRACKS MAY OCCUR IN THE BALL JOINT SOCKET.

POWER TRAIN:MANUAL TRANSMISSION

ON CERTAIN PASSENGER VEHICLES WITH MANUAL TRANSMISSIONS, THE HEAT INSULATOR MAY BE CRACKED CAUSING ABNORMAL NOISE.

AIR BAGS:FRONTAL

AS A RESULT OF AN NCAP TEST, CERTAIN PASSENGER VEHICLES ARE BEING RECALLED FOR IMPROPERLY WIRED FRONT PASSENGER SEAT AIR BAGS.

AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE

Mazda North America Operations (Mazda) is recalling certain 2003-2008 Mazda6, 2006-2007 Mazdaspeed6 and 2004 MPV vehicles nationwide. Mazda is also recalling 2005-2006 MPV vehicles in Alabama, Arizona, Arkansas, California, Delaware, the District of Columbia, Florida, Georgia, Hawaii, Illinois, Ind

ENGINE AND ENGINE COOLING

IF CERTAIN PASSENGER VEHICLES ARE PARKED AND THE ENGINE IS OPERATED AT HIGH RPM'S FOR AN EXCESSIVE LENGTH OF TIME, SOME OF THE PARTS AROUND THE EXHAUST SYSTEM CAN MELT AND PRODUCE A VARIETY OF MALFUNCTIONS. PROBLEMS CAUSED BY THE EXCESSIVE HEAT BUILD-UP CAN RANGE FROM INOPERATIVE OXYGEN SENSOR, NEU

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

Mazda North America Operations (Mazda) is recalling certain model year 2004-2008 RX-8 vehicles. Heat from the engine and the exhaust may cause the main fuel pump pipe to crack.

SUSPENSION:FRONT:CONTROL ARM:LOWER ARM

Mazda North American Operations (Mazda) is recalling certain 2004 Mazda RX-8 vehicles. The ball joint socket on the front suspension lower control arm may crack and the ball joint may separate from the socket.

ON 10/19/19 THE VEHICLE WAS INVOLVED IN A CRASH WHEN SWERVING TO AVOID A DEER ON THE ROAD. TWO TREES WERE HIT AND THE VEHICLE WAS FLIPPED ON ITS SIDE. NO AIRBAGS DEPLOYED DURING THIS ACCIDENT AS I WAS EXPECTED. PICTURES SHOW THE FRONT DAMAGE AND INTERIOR.

Mileage: 90,000

AS I PRESSED MY CARS CLUTCH TO CHANGE GEARS (6 SPEED MANUAL ) WHILE DRIVING ON MY REGULAR SUNDAY DRIVE IN A CITY STREET, I HEARD AND FELT A VERY LOUD EXPLOSION AND NOISES OF METAL PIECES EJECTING FROM UNDER MY CAR. I WAS IN THE 60KM/H ZONE SO WAS NOT SPEEDING OR GOING FAST SUCH AS ON A FREEWAY ETC. I WAS ABLE TO PULL OVER SAFELY WHILE ROLLING AS THE ENGINE HAD BEEN DISABLED IN THE EXPLOSION. I COULD FEEL MY LEFT FOOT WAS IN EXTREME PAIN. MY CAR WOULD NOT START. I FEARED THAT THE ENGINE HAD BLOWN

Mileage: 112,000

AS I PRESSED MY CARS CLUTCH TO CHANGE GEARS (6 SPEED MANUAL ) WHILE DRIVING ON MY REGULAR SUNDAY DRIVE IN A CITY STREET, I HEARD AND FELT A VERY LOUD EXPLOSION AND NOISES OF METAL PIECES EJECTING FROM UNDER MY CAR. I WAS IN THE 60KM/H ZONE SO WAS NOT SPEEDING OR GOING FAST SUCH AS ON A FREEWAY ETC. I WAS ABLE TO PULL OVER SAFELY WHILE ROLLING AS THE ENGINE HAD BEEN DISABLED IN THE EXPLOSION. I COULD FEEL MY LEFT FOOT WAS IN EXTREME PAIN. MY CAR WOULD NOT START. I FEARED THAT THE ENGINE HAD BLOWN

Mileage: 112,000

"TAKATA RECALL"-CAR STARTS WHEN COLD,THEN IT DIES IN THE TRAFFIC,GOT ENGERYS PUSHING CAR OUT OF TRAFFIC,LIKE CAR BUT IT HAS LOTS OF RECALLS AND NEEDS TO BE FIXED RIGHT AWAY.WON'T DRIVE MADZA 2004 AFTER THIS HAPPENED. *TT THE CONSUMER STATED WHILE ATTEMPTING TO PUSH THE CAR OFF OF THE HIGHWAY, AFTER IT DIED, HE LOST HIS GRIP AND WAS DRAGGED BEHIND THE VEHICLE. *JS

"TAKATA RECALL"-CAR STARTS WHEN COLD,THEN IT DIES IN THE TRAFFIC,GOT ENGERYS PUSHING CAR OUT OF TRAFFIC,LIKE CAR BUT IT HAS LOTS OF RECALLS AND NEEDS TO BE FIXED RIGHT AWAY.WON'T DRIVE MADZA 2004 AFTER THIS HAPPENED. *TT THE CONSUMER STATED WHILE ATTEMPTING TO PUSH THE CAR OFF OF THE HIGHWAY, AFTER IT DIED, HE LOST HIS GRIP AND WAS DRAGGED BEHIND THE VEHICLE. *JS

"TAKATA RECALL"-CAR STARTS WHEN COLD,THEN IT DIES IN THE TRAFFIC,GOT ENGERYS PUSHING CAR OUT OF TRAFFIC,LIKE CAR BUT IT HAS LOTS OF RECALLS AND NEEDS TO BE FIXED RIGHT AWAY.WON'T DRIVE MADZA 2004 AFTER THIS HAPPENED. *TT THE CONSUMER STATED WHILE ATTEMPTING TO PUSH THE CAR OFF OF THE HIGHWAY, AFTER IT DIED, HE LOST HIS GRIP AND WAS DRAGGED BEHIND THE VEHICLE. *JS

ON SEPTEMBER 15TH, 2016 I HAD STOPPED TO VACUUM OUT MY CAR AT A CAR WASH ON HIGHWAY 11 IN ATTALLA, AL. UPON LEAVING THE CAR WASH I TURNED LEFT ONTO PLEASANT VALLEY RD AT A SLOW SPEED IN FIRST GEAR. AS I WAS TURNING I SHIFTED INTO SECOND GEAR I HEAR A BREAKING NOISE AND THE STEERING WHEEL ABRUPTLY SPUN TO THE LEFT AS THE CAR WENT IN A DEEP DITCH FLIPPING ONTO ITS ROOF, THEN HITTING A SMALL CULVERT AND LANDING ON IT'S SIDE. AS I WAS INSPECTING THE VEHICLE TO SEE WHAT MIGHT HAVE HAPPENED, THE PASSE

Mileage: 100,051

ON SEPTEMBER 15TH, 2016 I HAD STOPPED TO VACUUM OUT MY CAR AT A CAR WASH ON HIGHWAY 11 IN ATTALLA, AL. UPON LEAVING THE CAR WASH I TURNED LEFT ONTO PLEASANT VALLEY RD AT A SLOW SPEED IN FIRST GEAR. AS I WAS TURNING I SHIFTED INTO SECOND GEAR I HEAR A BREAKING NOISE AND THE STEERING WHEEL ABRUPTLY SPUN TO THE LEFT AS THE CAR WENT IN A DEEP DITCH FLIPPING ONTO ITS ROOF, THEN HITTING A SMALL CULVERT AND LANDING ON IT'S SIDE. AS I WAS INSPECTING THE VEHICLE TO SEE WHAT MIGHT HAVE HAPPENED, THE PASSE

Mileage: 100,051

TL* THE CONTACT OWNS A 2004 MAZDA RX-8. WHILE DRIVING THROUGH A DRIVE-THRU WINDOW, THE VEHICLE STALLED. THE VEHICLE WAS PUSHED TO A PARKING SPACE. WHILE ATTEMPTING TO START THE VEHICLE, A LOUD POP SOUND EMERGED FROM THE ENGINE COMPARTMENT. IMMEDIATELY AFTERWARDS, SMOKE AND FLAMES APPEARED. THE FIRE DEPARTMENT EXTINGUISHED THE FLAMES. A POLICE REPORT WAS FILED. THE VEHICLE WAS NOT EVALUATED BY THE INSURANCE COMPANY. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT TAKEN TO A

Mileage: 150,000

TL* THE CONTACT OWNS A 2004 MAZDA RX-8. WHILE DRIVING 45 MPH, A BURNING ODOR ENTERED THE VEHICLE. THE CONTACT STOPPED THE VEHICLE, LIFTED THE HOOD, AND NOTICED SMOKE. THE CONTACT OBSERVED THAT THE WIRES UNDERNEATH THE HOOD WERE MELTED. THE CONTACT ALSO SMELLED FUEL COMING FROM THE REAR OF THE VEHICLE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC IN LOUISVILLE, KENTUCKY WHO DIAGNOSED THAT THE WIRING HARNESS HAD MELTED DUE TO A FAULTY ELECTRONIC CONTROL MODULE. THE VEHICLE WAS REPAIRED. THE MA

Mileage: 136,777

THERE HAS BEEN COUNTLESS TIMES WHERE I AM DRIVING AND MY STEERING JUST WANTS TO FAIL. OK SO NOW IT FAILS AND SOMETIMES, WITHOUT WARNING, JERKS MY WHEEL ONE DIRECTION. IF I AM NOT PAYING ATTENTION I COULD EASILY SIDESWIP ANOTHER CAR. IT HAS DONE IT WHILE DRIVING 55 MPH AND I HAVE HIT THE CENTER MEDIUM BENDING MY RIM AND DESTROYING MY TIRE. I HAVE BROUGHT IT INTO THE DEALERSHIP AND THEY CAN NEVER GET IT WITH THE LIGHT ON. I HAVE PAID FOR TWO DIAGNOSTICS WHERE THEY HAVE NOT BEEN ABLE TO DIAGNOS THE

Mileage: 124,000

TAKATA RECALL. TRAFFIC CAME TO A HALT ON THE FREEWAY. I STOPPED AND WAS SUBSEQUENTLY REAR ENDED AT HIGH SPEED CAUSING THE DRIVER SIDE AND PASSENGER SIDE AIR BAGS TO DEPLOY. EITHER THE AIR BAG ITSELF OR A PROJECTILE INJURED MY EYE. THE SKIN ON MY EYELID WAS TORN REQUIRING 7 STITCHES. THIS WAS EXTREMELY TRAUMATIC AND I WANTED TO BE SURE THIS INCIDENT WAS INCLUDED IN THE INVESTIGATION.

Mileage: 56,000

TL* THE CONTACT OWNS A 2004 MAZDA RX-8. WHILE DRIVING 25 MPH, THE CONTACT'S VEHICLE WAS REAR ENDED BY ANOTHER VEHICLE. AS A RESULT, THE CONTACT REAR ENDED THE PRECEDING VEHICLE. THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS FILED. THE CONTACT RECEIVED NECK AND BACK PAIN THAT REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS NOT TOWED AND WAS ABLE TO BE DRIVEN AFTER THE CRASH. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 15V345000 (AIR BAGS) AND 15V382000 (AIR BAGS); HOWEVER, THE P

Mileage: 89,400

TL* THE CONTACT OWNS A 2004 MAZDA RX-8. THE CONTACT STATED THAT WHILE AT A STOP LIGHT, THE FRONT DRIVER SIDE AIR BAGS DEPLOYED WITH EXCESSIVE FORCE AND RUPTURED. THE CONACT SUSTAINED UNKNOWN INJURIES BUT MEDICAL ATTENTION WAS NOT REQUIRED. THE VEHICLE WAS DRIVEN TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 89,982.

Mileage: 89,982

TL* THE CONTACT OWNS A 2004 MAZDA RX-8. WHILE DRIVING AT 70 MPH, THE STEERING WHEEL INDEPENDENTLY TURNED IN BOTH DIRECTIONS. AS A RESULT, THE CONTACT CRASHED INTO A CURB AND THE AIR BAGS FAILED TO DEPLOY. THE CONTACT DID NOT SUSTAIN ANY INJURIES. A POLICE REPORT WAS NOT FILED. IN ADDITION, THE CONTACT NOTICED THAT THE REAR PASSENGER WHEEL WELL WAS CURVED AND FRACTURED. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN WAS UNABLE TO DIAGNOSE OR REPAI

Mileage: 95,000

TL* THE CONTACT OWNS A 2004 MAZDA RX-8. WHILE DRIVING AT 70 MPH, THE STEERING WHEEL INDEPENDENTLY TURNED IN BOTH DIRECTIONS. AS A RESULT, THE CONTACT CRASHED INTO A CURB AND THE AIR BAGS FAILED TO DEPLOY. THE CONTACT DID NOT SUSTAIN ANY INJURIES. A POLICE REPORT WAS NOT FILED. IN ADDITION, THE CONTACT NOTICED THAT THE REAR PASSENGER WHEEL WELL WAS CURVED AND FRACTURED. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN WAS UNABLE TO DIAGNOSE OR REPAI

Mileage: 95,000

TL* THE CONTACT OWNS A 2004 MAZDA RX-8. WHILE DRIVING AT 70 MPH, THE STEERING WHEEL INDEPENDENTLY TURNED IN BOTH DIRECTIONS. AS A RESULT, THE CONTACT CRASHED INTO A CURB AND THE AIR BAGS FAILED TO DEPLOY. THE CONTACT DID NOT SUSTAIN ANY INJURIES. A POLICE REPORT WAS NOT FILED. IN ADDITION, THE CONTACT NOTICED THAT THE REAR PASSENGER WHEEL WELL WAS CURVED AND FRACTURED. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN WAS UNABLE TO DIAGNOSE OR REPAI

Mileage: 95,000

TL* THE CONTACT OWNS A 2004 MAZDA RX-8. THE CONTACT STATED THAT WHILE AT A STOP LIGHT, THE VEHICLE STARTED TO SHAKE AND JERK FORWARD. THE CONTACT ACCELERATED AND THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT RESTARTED THE ENGINE BUT BLACK SMOKE WAS SEEN FROM EXHAUST. THE VEHICLE WAS UNABLE TO BE DRIVEN. THE CONTACT HAD THE VEHICLE TOWED TO A LOCAL MECHANIC, WHO STATED THAT THE ENGINE HAD EXPERIENCED AN INTERNAL FIRE. THE MECHANIC ADVISED THE CONTACT THAT THE ENTIRE ENGINE NEEDED TO BE REBUILT

Mileage: 93,700

POWER STEERING INTERMITTENTLY GOES OUT. A SEARCH OF THE INTERNET INDICATES THAT THIS IS A KNOWN PROBLEM FOR MAZDA YET THERE ARE NO RECALLS TO FIX FAULTY ENGINEERING. THE RADIATOR OVERFLOW LEAKS ONTO THE CONNECTORS FOR THE ELECTRIC POWER STEERING CAUSING CORROSION AND SPORADIC CONNECTIONS. *TR

Mileage: 98,000

TL* THE CONTACT OWNS A 2004 MAZDA RX-8. THE CONTACT STATED THE DRIVER WAS TRAVELING 35 MPH WHEN A VEHICLE CROSSED THE CENTER LANE CRASHING INTO A VEHICLE IN FRONT OF THE CONTACT CAUSING THAT VEHICLE TO CRASH INTO THE CONTACT. THE VEHICLE WAS HIT ON THE DRIVERS SIDE DOOR. THE AIR BAG IN THE STEERING WHEEL DID NOT DEPLOY AS THE STEERING WHEEL DETACHED FROM THE STEERING COLUMN. THE SIDE AIR BAGS DID DEPLOY. THE PASSENGER SIDE AIR BAGS DID NOT DEPLOY. THE DRIVER SUFFERED A CRUSHED PELVIS, TAIL BONE