2002 KIA OPTIMA

SUSPENSION:FRONT

KIA MOTORS CORPORATION (KMC) IS RECALLING 36,538 MODEL YEAR 2001-2004 OPTIMA VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO,

FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY

SOME PASSENGER VEHICLES MAY CONTAIN A FUEL TANK ASSEMBLY VALVE THAT MAY NOT CLOSE PROPERLY. IF A VEHICLE WITH A FUEL TANK ASSEMBLY VALVE THAT IS NOT PROPERLY CLOSED WERE TO ROLL OVER, FUEL SPILLAGE MAY OCCUR.

ELECTRICAL SYSTEM:STARTER ASSEMBLY

ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.5 AND 2.7 LITER V6 ENGINES, THE CRANKSHAFT POSITION SENSOR (CKP) CASES DID NOT MEET DIMENSIONAL SPECIFICATIONS.

TL* THE CONTACT OWNED A 2002 KIA OPTIMA. WHILE DRIVING AT AN UNKNOWN SPEED, THE VEHICLE HYDROPLANED AND CRASHED INTO A TREE. THE AIR BAGS FAILED TO DEPLOY. THERE WERE NO INJURIES AND A POLICE REPORT WAS FILED. THE VEHICLE WAS DESTROYED AND TOWED. THE DEALER WAS NOT CONTACTED AND THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 219,000.

Mileage: 219,000

TL* THE CONTACT OWNS A 2002 KIA OPTIMA. AFTER STARTING THE VEHICLE, FLAMES STARTED TO EMIT FROM UNDERNEATH THE HOOD DUE TO THE WIRING NEAR THE STARTER. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 220,000.

Mileage: 220,000

TL* THE CONTACT OWNS A 2002 KIA OPTIMA. AFTER STARTING THE VEHICLE, FLAMES STARTED TO EMIT FROM UNDERNEATH THE HOOD DUE TO THE WIRING NEAR THE STARTER. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 220,000.

Mileage: 220,000

A FIRE STARTED INSIDE THE DRIVERS SIDE DOOR PANEL FILLING THE CAR WITH HEAVY BLACK SMOKE MY WIFE OPENED THE DRIVERS SIDE ELECTRIC WINDOW TO GE RID OF THE SMOKE OUT OF THE CAR. SHE DROVE THE CAR INTO HER BACK YARD AND STARTED SCREAMING FOR HELP SINCE THE DRIVERS SIDE DOOR WOULD NOT OPEN. HER HUSBAND RAN TO THE BACK YARD AND WAS ABLE TO OPEN THE PASSENGER SIDE DOOR AND SHE HAD TO CLIMB OVER THE GEAR SHIFT AND THE EMERGENCY BRAKE TO GET OUT OF THE CAR. SHE WAS ON OXYGEN AT THE TIME. HER HUSBAN

Mileage: 62,200

MY 2002 KIA OPTIMA, VEERED OF THE SIDE OF THE INTERSTATE DUE TO A FLAT TIRE. THE TIRES HAD BEEN REPLACED THAT MORNING AND WITHIN 130 MILES ON THE HIGHWAY THE RIGHT FRONT TIRE POPPED. AS I TOOK A CLOSER LOOK I NOTICED MY WHEEL WAS SLANTED IN. I THEN HAD IT TOWED TO THE NEAREST REPAIR SHOP WHO INFORMED ME THE ENGINE CRADLE WAS RUSTED AND CORRODED. WHEN I CONTACTED KIA ABOUT THE ISSUE THEY BASICALLY SAID SORRY ABOUT YOUR LUCK. THERE IS A RECALL FOR THIS PROBLEM BUT MY VIN IS NOT INCLUDED. NO ACTION

Mileage: 140,000

MY 2002 KIA OPTIMA, VEERED OF THE SIDE OF THE INTERSTATE DUE TO A FLAT TIRE. THE TIRES HAD BEEN REPLACED THAT MORNING AND WITHIN 130 MILES ON THE HIGHWAY THE RIGHT FRONT TIRE POPPED. AS I TOOK A CLOSER LOOK I NOTICED MY WHEEL WAS SLANTED IN. I THEN HAD IT TOWED TO THE NEAREST REPAIR SHOP WHO INFORMED ME THE ENGINE CRADLE WAS RUSTED AND CORRODED. WHEN I CONTACTED KIA ABOUT THE ISSUE THEY BASICALLY SAID SORRY ABOUT YOUR LUCK. THERE IS A RECALL FOR THIS PROBLEM BUT MY VIN IS NOT INCLUDED. NO ACTION

Mileage: 140,000

MY 2002 KIA OPTIMA, VEERED OF THE SIDE OF THE INTERSTATE DUE TO A FLAT TIRE. THE TIRES HAD BEEN REPLACED THAT MORNING AND WITHIN 130 MILES ON THE HIGHWAY THE RIGHT FRONT TIRE POPPED. AS I TOOK A CLOSER LOOK I NOTICED MY WHEEL WAS SLANTED IN. I THEN HAD IT TOWED TO THE NEAREST REPAIR SHOP WHO INFORMED ME THE ENGINE CRADLE WAS RUSTED AND CORRODED. WHEN I CONTACTED KIA ABOUT THE ISSUE THEY BASICALLY SAID SORRY ABOUT YOUR LUCK. THERE IS A RECALL FOR THIS PROBLEM BUT MY VIN IS NOT INCLUDED. NO ACTION

Mileage: 140,000

DT*: THE CONTACT STATED THAT THERE WERE TWO ACCIDENTS WITH THE VEHICLE WHERE THE AIR BAG DID NOT DEPLOY. IN THE FIRST ACCIDENT, IN 2003, NONE OF THE AIRBAGS DEPLOYED. IN THE SECOND OF THESE ACCIDENTS WHICH WAS MORE SEVERE, THE VEHICLE WAS TOTALED, AND NONE OF THE AIRBAGS DEPLOYED EITHER. IN THE BOTH ACCIDENTS, THE OCCUPANT WERE WEARING THEIR SEATBELTS HOWEVER THE CONTACT EXPRESSED CONCERN THAT THERE MUST BE A PROBLEM AIR BAG SENSOR OF THE VEHICLE.

DT*: THE CONTACT STATED THAT WHILE DRIVING AT 40 MPH, THE VEHICLE WAS FILLED WITH THE SMELL OF BURNING RUBBER. THIS WAS CLOSELY FOLLOWED BY AN APPEARANCE OF WHITE SMOKE. THE SMOKE WAS COMING FROM THE SEAT BELT HARNESS AREA ON THE PASSENGER SIDE OF THE VEHICLE. THE VEHICLE WAS TAKEN TO A SERVICE DEALER, WHERE THE DEALER WAS UNABLE TO DETERMINE THE PROBLEM.

Mileage: 121,000

WHILE DRIVING ON A PAVED SURFACE GOING APPROX. 40 MPH, MY DRIVER SIDE SEAT AIRBAG WENT OFF FOR NO REASON. I SUSTAINED SEVERE BRUISING AND BURNING SCABS ON MY LEFT SHOULDER AND CURRENTLY HAVE A SCAR THERE. *NM

Mileage: 97,000

DT*: THE CONTACT STATED THE DRIVER SIDE AIRBAG DEPLOYED WITHOUT WARNING WHILE DRIVING 35MPH. THE DRIVER SEAT BELT WAS IN USE AT THE TIME OF THE INCIDENT AND THE BRAKES WERE NOT BEING APPLIED. THE SUDDEN DEPLOYMENT OF THE AIRBAG STARTLED THE CONTACT AND THE STEERING WHEEL WAS JERKED IN REACTION TO THE AIRBAG. THE VEHICLE LEFT THE ROADWAY AND STRUCK A CURB, THE VEHICLE SUSTAINED DAMAGE TO THE PASSENGER SIDE AND THE OIL PAN WAS RUPTURED. THE VEHICLE WAS TOWED TO A SERVICE DEALER WHO DETERMINED

Mileage: 48,000

2002 KIA OPTIMA AIRBAG DRIVER'S SIDE DEPLOYED GOING 35 MILES PERHOUR WHILE IN A RIGHT HAND CURVE. WHEN THE AIR BAG DEPLOYED IT HIT THE LEFT SHOUDER CAUSING MY DAUGHTER TO TURN THE WHEEL MORE AND GO OFF THE ROAD. THERE WHERE NO IMPACTS ON ANY PART OF THE CAR .WE ARE LUCKY NO ONE WAS HURT OTHER THAN A STRAINED NECK AND A HOLE IN THE OIL PAN. KIA RECALLED SOME 2001 FOR THE SAME PROBLEM .*AK

Mileage: 48,000

DT: 2002 KIA OPTIMA LX. THERE IS AN ELECTRICAL PROBLEM WITH THE VEHICLE. THE LIGHTS WILL START TO FLICKER, AND THEN THE VEHICLE WILL LOSE POWER AND SHUT EVERYTHING DOWN. WHEN THE TEMPERATURE WAS AROUND 80-90 DEGREES AND AT LONG DISTANCES THIS PROBLEM WILL HAPPEN. THE DEALERSHIP CHANGED THE BATTERY TWICE, THE ALTERNATOR TWICE, THE MAIN WIRING HARNESS, AND THE MAIN COMPUTER FOR THE VEHICLE. THIS STILL DID NOT FIX THE PROBLEM. CONSUMER TOOK VEHICLE BACK TO THE DEALERSHIP WHEN THE POWER WE

Mileage: 44,185

DT: 2002 KIA OPTIMA LX. THERE IS AN ELECTRICAL PROBLEM WITH THE VEHICLE. THE LIGHTS WILL START TO FLICKER, AND THEN THE VEHICLE WILL LOSE POWER AND SHUT EVERYTHING DOWN. WHEN THE TEMPERATURE WAS AROUND 80-90 DEGREES AND AT LONG DISTANCES THIS PROBLEM WILL HAPPEN. THE DEALERSHIP CHANGED THE BATTERY TWICE, THE ALTERNATOR TWICE, THE MAIN WIRING HARNESS, AND THE MAIN COMPUTER FOR THE VEHICLE. THIS STILL DID NOT FIX THE PROBLEM. CONSUMER TOOK VEHICLE BACK TO THE DEALERSHIP WHEN THE POWER WE

Mileage: 44,185

DT: 2002 KIA OPTIMA LX. THERE IS AN ELECTRICAL PROBLEM WITH THE VEHICLE. THE LIGHTS WILL START TO FLICKER, AND THEN THE VEHICLE WILL LOSE POWER AND SHUT EVERYTHING DOWN. WHEN THE TEMPERATURE WAS AROUND 80-90 DEGREES AND AT LONG DISTANCES THIS PROBLEM WILL HAPPEN. THE DEALERSHIP CHANGED THE BATTERY TWICE, THE ALTERNATOR TWICE, THE MAIN WIRING HARNESS, AND THE MAIN COMPUTER FOR THE VEHICLE. THIS STILL DID NOT FIX THE PROBLEM. CONSUMER TOOK VEHICLE BACK TO THE DEALERSHIP WHEN THE POWER WE

Mileage: 44,185

DT: 2002 KIA OPTIMA LX. THERE IS AN ELECTRICAL PROBLEM WITH THE VEHICLE. THE LIGHTS WILL START TO FLICKER, AND THEN THE VEHICLE WILL LOSE POWER AND SHUT EVERYTHING DOWN. WHEN THE TEMPERATURE WAS AROUND 80-90 DEGREES AND AT LONG DISTANCES THIS PROBLEM WILL HAPPEN. THE DEALERSHIP CHANGED THE BATTERY TWICE, THE ALTERNATOR TWICE, THE MAIN WIRING HARNESS, AND THE MAIN COMPUTER FOR THE VEHICLE. THIS STILL DID NOT FIX THE PROBLEM. CONSUMER TOOK VEHICLE BACK TO THE DEALERSHIP WHEN THE POWER WE

Mileage: 44,185

WHILE DRIVING AN ACCIDENT OCCURRED. THE VEHICLE FLIPPED AFTER HITTING A POLE. UPON IMPACT, THE FRONTAL/SIDE AIR BAGS DID NOT DEPLOY. *AK *SC THE CONSUMER HAD A DIABETIC EMERGENCY AND COLLAPSED AT THE WEHEL. *JB

WHILE DRIVING MY 2002 KIA OPTIMA, MY STEREO,HEADLIGHTS,DASHLIGHTS WOULD CUT OUT WHILE DRIVING. I TOOK IT IN TO A KIA DEALERSHIP, THE INSTRUCTED ME TO GET A NEW BATTERY. I DID, AND THAT DID NOT FIX THE PROBLEM. ON SATURDAY, JANUARY 1RST,2005 I WAS DRIVING DOWN THE FREEWAY DOING ABOUT 60 MPH, MY CAR LOST ALL POWER AND STALLED IN THE MIDDLE OF THE FREEWAY. I COULD NOT WARN OTHER DRIVERS BEHIND ME BECAUSE MY HAZARD LIGHTS WOULD NOT TURN ON, I HAD NO ELECTRICAL POWER TO MY CAR. IT ALMOST CAUSED PEOPL

Mileage: 52

WHILE DRIVING MY 2002 KIA OPTIMA, MY STEREO,HEADLIGHTS,DASHLIGHTS WOULD CUT OUT WHILE DRIVING. I TOOK IT IN TO A KIA DEALERSHIP, THE INSTRUCTED ME TO GET A NEW BATTERY. I DID, AND THAT DID NOT FIX THE PROBLEM. ON SATURDAY, JANUARY 1RST,2005 I WAS DRIVING DOWN THE FREEWAY DOING ABOUT 60 MPH, MY CAR LOST ALL POWER AND STALLED IN THE MIDDLE OF THE FREEWAY. I COULD NOT WARN OTHER DRIVERS BEHIND ME BECAUSE MY HAZARD LIGHTS WOULD NOT TURN ON, I HAD NO ELECTRICAL POWER TO MY CAR. IT ALMOST CAUSED PEOPL

Mileage: 52

WHILE DRIVING MY 2002 KIA OPTIMA, MY STEREO,HEADLIGHTS,DASHLIGHTS WOULD CUT OUT WHILE DRIVING. I TOOK IT IN TO A KIA DEALERSHIP, THE INSTRUCTED ME TO GET A NEW BATTERY. I DID, AND THAT DID NOT FIX THE PROBLEM. ON SATURDAY, JANUARY 1RST,2005 I WAS DRIVING DOWN THE FREEWAY DOING ABOUT 60 MPH, MY CAR LOST ALL POWER AND STALLED IN THE MIDDLE OF THE FREEWAY. I COULD NOT WARN OTHER DRIVERS BEHIND ME BECAUSE MY HAZARD LIGHTS WOULD NOT TURN ON, I HAD NO ELECTRICAL POWER TO MY CAR. IT ALMOST CAUSED PEOPL

Mileage: 52