2021 HYUNDAI KONA ELECTRIC

ELECTRICAL SYSTEM:PROPULSION SYSTEM:TRACTION BATTERY:THERMAL MANAGEMENT:FLUID/COOLANT

Hyundai Motor America (Hyundai) is recalling certain 2021 Kona EV vehicles. The Electric Power Control Unit (EPCU) may have been improperly sealed and may leak coolant internally.

SERVICE BRAKES, HYDRAULIC:POWER ASSIST:ELECTRIC:CONTROL MODULE:SOFTWARE

Hyundai Motor America (Hyundai) is recalling certain 2019-2020 Nexo Fuel Cell and 2019-2021 Kona Electric vehicles. The Integrated Electronic Brake (IEB) system may detect an abnormal sensor signal and as a result, may significantly reduce braking performance.

File with NHTSA now please!!!! What do you have to lose??? If anything If they do an investigation we are safe post warranty. Report a Vehicle Safety Problem, Equipment Issue | NHTSA [XXX] The Hyundai Kona Electric Vehicle (EV) has experienced issues with its Integrated Charging Control Unit (ICCU) due to problems with the low-conductivity coolant (BSC-1) used in models produced between 2018 and October 2021. This coolant can crystallize, forming debris that clogs the cooling system, leadi

Potential Fire and safety risk ... The Hyundai Kona Electric Vehicle (EV) has experienced issues with its Integrated Charging Control Unit (ICCU) due to problems with the low-conductivity coolant (BSC-1) used in models produced between 2018 and October 2021. This coolant can crystallize, forming debris that clogs the cooling system, leading to false "Refill Inverter Coolant" warnings and potential overheating risks. A Technical Service Bulletin (TSB 23-01-049H) outlines a recall to flush and re

Manufacturing defect ... Took it in 4 times for "refill inverter coolant" warning . They had a campaign ' tried by couldn't get the light to go away . It was their first time ever performing this on an EV at Kerry hyundai alexandria . Now TD EV in mason Ohio is confirming my inverter failed as a direct result of the poor flushes and poor manufacturing. I am seeking for hyundai to cover all related costs. I haven't had my vehicle for over a month . It's out of warranty 'however this was

Hyundia has had my car in for the SAME recall 4 to 5 times . 6 total weeks this time around. The ""refill inverter coolant" light kept coming back on . The last time I got it home it had more issues than when I took it in and wouldn't even catch a charge . (EV) They fried my compassitor trying to fix the inverter coolant recall . I then took had to pay 450 for a diagnostic ' (Kerry hyundai alexandria) They said electric motor is bad and will cost 8000 to 9000. Got a 2nd diagnostic (Jeff wy

The car was unable to charge using level 3 DC fast chargers, necessitating the use of a level 2 charger for an extended length of time in order to be able to return home. A Hyundai dealer replaced the charging inlet lock actuator (invoice attached).

The car was unable to charge using level 3 DC fast chargers, necessitating the use of a level 2 charger for an extended length of time in order to be able to return home. A Hyundai dealer replaced the charging inlet lock actuator (invoice attached).

After powering on the car, the dashboard displayed multiple brake system warnings, including the brake system warning light and a message on the LCD display that read "Check regenerative brakes." A Hyundai dealer replaced the integrated electric brake unit assembly (invoice attached).

My wife's car t-boned another vehicle, but the air bags didn't deploy. Luckily, she wasn't hurt badly, but the vehicle was deemed a total loss, so you can imagine the force of the collision. The forward collision warning and automatic emergency braking didn't activate either. I reported it to Hyundai. They sent an inspector to examine the vehicle, and I also showed them photos and a copy of the police report, but they claim that my car was hit on the side, and the pre collision system doesn't de

My wife's car t-boned another vehicle, but the air bags didn't deploy. Luckily, she wasn't hurt badly, but the vehicle was deemed a total loss, so you can imagine the force of the collision. The forward collision warning and automatic emergency braking didn't activate either. I reported it to Hyundai. They sent an inspector to examine the vehicle, and I also showed them photos and a copy of the police report, but they claim that my car was hit on the side, and the pre collision system doesn't de

My wife's car t-boned another vehicle, but the air bags didn't deploy. Luckily, she wasn't hurt badly, but the vehicle was deemed a total loss, so you can imagine the force of the collision. The forward collision warning and automatic emergency braking didn't activate either. I reported it to Hyundai. They sent an inspector to examine the vehicle, and I also showed them photos and a copy of the police report, but they claim that my car was hit on the side, and the pre collision system doesn't de

Fill coolant warning came on, we checked the coolant and the coolant level was good. I spoke to a Hyundai service center and the rep said that sometimes this happens with Hyundais and it may go off. Indeed it did but then Fill coolant warning came back and the coolant level was still good. After several weeks of the Fill Coolant warning being on more often than not, the car started one morning but couldn’t be driven as the handbrake was stuck on, the fill coolant warning was on and the tire

The contact owns a 2021 Hyundai Kona Electric. The contact stated while the vehicle was parked, the rearview camera became inoperable. The contact stated that the image on the rearview camera went blank. There was no warning light illuminated. The vehicle was taken to the dealer, and it was diagnosed and determined that the tailgate wiring harness had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and offered to pay for 60 percent o

Mileage: 86,612

My vehicle has said, refill inverter coolant, I took it in a couple of days ago and they said there is an open recall and they would fix it. They called me back after I dropped it off and informed me that they did not have the specific coolant, and no one in the area did. Over the past couple days, my vehicle has had issues turning on.

The contact owns a 2021 Hyundai Kona Electric. The contact stated that the battery had discharged. The contact stated that the 12-volt battery and “Bring in for Service, and key not detected messages were displayed. The contact stated that while his mother was driving at an undisclosed speed, the vehicle stalled on two occasions. The vehicle flickered, and the vanity lights dimmed and flickered. The contact called the local dealer, where the vehicle was rebooted. The contact stated that five a

Mileage: 38,000

The contact owns a 2021 Hyundai Kona Electric. The contact stated that the battery had discharged. The contact stated that the 12-volt battery and “Bring in for Service, and key not detected messages were displayed. The contact stated that while his mother was driving at an undisclosed speed, the vehicle stalled on two occasions. The vehicle flickered, and the vanity lights dimmed and flickered. The contact called the local dealer, where the vehicle was rebooted. The contact stated that five a

Mileage: 38,000

While driving on the highway at 70 mph, cruise control engaged, there was a sudden loss of drive power. I could not accelerate, or return to the cruising speed. The speed just dramatically fell. The only remedy was to pull over to the side of the road, turn off the car, and start it again. This VIN was not included in the initial similar recall earlier this year.

The contact owns a 2021 Hyundai Kona Electric. The contact received notification of NHTSA Campaign Number: 22V941000 (Electrical System) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

July of 2022, vehicle went in due to battery not charging. Vehicle kept at Temecula Hyundai repair until September 2022 for EV battery replacement. Upon return, EV battery still didn't change. September 2022 vehicle went back for repairs. Returned October 2022. Was told battery overheating sensor was faulty and was turned off. As a result the EV battery will not be able to charge beyond 90%. Was told nothing else they could do to repair the car. When I asked if there was an increased risk of b

After just 18 months and about 5,000 miles, the heater/defroster system stopped working. My local Hyundai dealer (Dick Hannah Volkswagen/Hyundai) confirmed the failure. Even after installing a new heater unit, the dealer reported the system is still not working. My car has been at the dealer since 1-17-23. Having no defroster is a serious safety issue in the winter here in Portland, Oregon, as the car can become unsafe to drive when the windows fog-up (as is common in the winter here). Ther

After just 18 months and about 5,000 miles, the heater/defroster system stopped working. My local Hyundai dealer (Dick Hannah Volkswagen/Hyundai) confirmed the failure. Even after installing a new heater unit, the dealer reported the system is still not working. My car has been at the dealer since 1-17-23. Having no defroster is a serious safety issue in the winter here in Portland, Oregon, as the car can become unsafe to drive when the windows fog-up (as is common in the winter here). Ther