2005 GMC SIERRA 1500

FUEL SYSTEM, GASOLINE

CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CE

WHEELS:HUB

CERTAIN FEDERAL-MOGUL REPLACEMENT WHEEL HUB ASSEMBLIES WITH THE BRAND NAMES: NATIONAL, CARQUEST P/NOS. 515020, 515021, 515025, 515053, 515054, 515059, AND 515060, SHIPPED BETWEEN JANUARY 23, 2006, AND DECEMBER 20, 2007, SOLD FOR LIGHT DUTY AND MEDIUM DUTY TRUCKS. THE INBOARD RETENTION NUT USED TO M

SERVICE BRAKES, AIR

CERTAIN FEDERAL-MOGUL NATIONAL AND CARQUEST AFTERMARKET HUB ASSEMBLIES, P/N 515058, SOLD FOR USE ON 2001-2006 GENERAL MOTORS 1500 AND 2500 4WD TRUCKS. ON THE SUBJECT HUB ASSEMBLIES, THE ABS SENSOR CORD DEPARTS FROM THE HUB ASSEMBLY AT A 90 DEGREE ANGLE. AS A RESULT, THERE IS A FIT ISSUE WITH THE B

See attached document for complaint.

See attached document for complaint.

COMPLAINT ON GM EXHAUST MANIFOLD BOLT DEFECT, INFERIOR BRAKE/ FUEL LINES. MINE IS A 2005 GMC. DEFECTIVE EXHAUST BOLTS AFFECT 12 MILLION GM TRUCKS FROM 1999 TO 2007. GM EXHAUST BOLTS ARE TO SMALL BRITTLE FOR SECURING EXHAUST MANIFOLDS. BOLTS SNAP OFF CAUSING EXHAUST LEAKS. TRUCKS NOT PASSING EMISSIONS AND DANGEROUS EXHAUST FUMES ENTERING THE DRIVERS COMPARTMENT OF THE VEHICLES WHILE DRIVING. I AND MY FAMILY GET A CARBON MONOXIDE HEADACHE WHEN I DRIVE IT AND HAVE HAD TO PULL OVER TO

Mileage: 117,000

COMPLAINT ON GM EXHAUST MANIFOLD BOLT DEFECT, INFERIOR BRAKE/ FUEL LINES. MINE IS A 2005 GMC. DEFECTIVE EXHAUST BOLTS AFFECT 12 MILLION GM TRUCKS FROM 1999 TO 2007. GM EXHAUST BOLTS ARE TO SMALL BRITTLE FOR SECURING EXHAUST MANIFOLDS. BOLTS SNAP OFF CAUSING EXHAUST LEAKS. TRUCKS NOT PASSING EMISSIONS AND DANGEROUS EXHAUST FUMES ENTERING THE DRIVERS COMPARTMENT OF THE VEHICLES WHILE DRIVING. I AND MY FAMILY GET A CARBON MONOXIDE HEADACHE WHEN I DRIVE IT AND HAVE HAD TO PULL OVER TO

Mileage: 117,000

COMPLAINT ON GM EXHAUST MANIFOLD BOLT DEFECT, INFERIOR BRAKE/ FUEL LINES. MINE IS A 2005 GMC. DEFECTIVE EXHAUST BOLTS AFFECT 12 MILLION GM TRUCKS FROM 1999 TO 2007. GM EXHAUST BOLTS ARE TO SMALL BRITTLE FOR SECURING EXHAUST MANIFOLDS. BOLTS SNAP OFF CAUSING EXHAUST LEAKS. TRUCKS NOT PASSING EMISSIONS AND DANGEROUS EXHAUST FUMES ENTERING THE DRIVERS COMPARTMENT OF THE VEHICLES WHILE DRIVING. I AND MY FAMILY GET A CARBON MONOXIDE HEADACHE WHEN I DRIVE IT AND HAVE HAD TO PULL OVER TO

Mileage: 117,000

TL* THE CONTACT OWNS A 2005 GMC SIERRA 1500. WHILE DRIVING APPROXIMATELY 55 MPH IN THE RAIN, THE CONTACT SWITCHED LANES ON A CURVED ROAD AND THE VEHICLE STARTED TO SKID. THE REAR OF THE VEHICLE WAS OUT OF CONTROL. AS A RESULT, THE CONTACT CRASHED INTO A GUARDRAIL AND THEN A MEDIAN. THE AIR BAGS FAILED TO DEPLOY. THE CONTACT SUSTAINED NECK INJURIES THAT DID NOT REQUIRE MEDICAL ATTENTION. A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS TOWED TO AN AUTO COLLISION CENTER. THE VEHICLE WAS NOT REPAIRED

Mileage: 90,000

TL* THE CONTACT OWNS A 2005 GMC SIERRA 1500. THE CONTACT STATED THAT WHEN ACTIVATING THE A/C, THERE WAS SMOKE EMITTING FROM THE VENTS. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE THE VEHICLE WAS REPAIRED BUT THE REPAIRS WERE UNKNOWN. THE CONTACT ALSO STATED THAT THAT THE BRAKE PEDAL WAS APPLIED AND FAILED TO RESPOND. THE VEHICLE WAS TOWED TO A PRIVATE MECHANIC, WHO DIAGNOSED THAT THE ENTIRE BRAKE LINE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED THREE YEARS LAT

Mileage: 63,510

TL* THE CONTACT OWNS A 2005 GMC SIERRA 1500. THE CONTACT STATED THAT WHEN ACTIVATING THE A/C, THERE WAS SMOKE EMITTING FROM THE VENTS. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE THE VEHICLE WAS REPAIRED BUT THE REPAIRS WERE UNKNOWN. THE CONTACT ALSO STATED THAT THAT THE BRAKE PEDAL WAS APPLIED AND FAILED TO RESPOND. THE VEHICLE WAS TOWED TO A PRIVATE MECHANIC, WHO DIAGNOSED THAT THE ENTIRE BRAKE LINE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED THREE YEARS LAT

Mileage: 63,510

TL* THE CONTACT OWNS A 2005 GMC SIERRA 1500. THE CONTACT STATED THAT WHEN ACTIVATING THE A/C, THERE WAS SMOKE EMITTING FROM THE VENTS. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE THE VEHICLE WAS REPAIRED BUT THE REPAIRS WERE UNKNOWN. THE CONTACT ALSO STATED THAT THAT THE BRAKE PEDAL WAS APPLIED AND FAILED TO RESPOND. THE VEHICLE WAS TOWED TO A PRIVATE MECHANIC, WHO DIAGNOSED THAT THE ENTIRE BRAKE LINE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED THREE YEARS LAT

Mileage: 63,510

WHILE DRIVING FORWARD IN TRAFFIC WHEN CAR CUT IN FRONT FROM THE NEXT LANE TO THE RIGHT. THIS REQUIRED EMERGENCY BRAKING, BUT MY SPEED WAS SLOW AND TRUCK SHOULD HAVE STOPPED WITHIN THE SPACE AVAILABLE AND THE TRUCK BRAKES SEEMED TO FEEL AS IF THEY RELEASED ON THEIR OWN. DAMAGE OCCURRED TO THE CAR I REAR ENDED AND THEY REAR-ENDED A CAR IN FRONT OF THEM. DAMAGE TO ALL 3 VEHICLES WAS LIGHT ENOUGH THAT ALL WERE DRIVEN AWAY AFTER CRASH. ON THE WAY HOME I NOTICED THE BRAKES WERE NOT WORKING PROPERL

Mileage: 177,000

TL*THE CONTACT OWNS A 2005 GMC SIERRA 1500. WHILE DRIVING AT 65 MPH, THE CONTACT NOTICED THAT THE ABS LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. AN HOUR LATER, THE CONTACT NOTICED THAT THE VEHICLE DISPLAYED DIFFICULTY STOPPING. AFTER INSPECTING THE VEHICLE, THE CONTACT NOTICED THAT THE DRIVER SIDE TIRE WAS TILTED AND SMOKE AND FLAMES HAD BEGAN RISING FROM BEHIND THE WHEEL. THE CONTACT CALLED THE FIRE DEPARTMENT BUT NO REPORT WAS FILED. THE VEHICLE HAD NOT BEEN INSPECTED AT THE TIME OF THE COMPLA

Mileage: 49,000

TL*THE CONTACT OWNS A 2005 GMC SIERRA 1500. WHILE DRIVING AT 65 MPH, THE CONTACT NOTICED THAT THE ABS LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. AN HOUR LATER, THE CONTACT NOTICED THAT THE VEHICLE DISPLAYED DIFFICULTY STOPPING. AFTER INSPECTING THE VEHICLE, THE CONTACT NOTICED THAT THE DRIVER SIDE TIRE WAS TILTED AND SMOKE AND FLAMES HAD BEGAN RISING FROM BEHIND THE WHEEL. THE CONTACT CALLED THE FIRE DEPARTMENT BUT NO REPORT WAS FILED. THE VEHICLE HAD NOT BEEN INSPECTED AT THE TIME OF THE COMPLA

Mileage: 49,000

TL*THE CONTACT OWNS A 2005 GMC SIERRA 1500. WHEN THE VEHICLE IS SHIFTED INTO FIFTH GEAR, THE FAN STOPS BLOWING. WHEN SWITCHING BACK TO FOURTH GEAR, THE FAN WILL BLOW. THE FAILURE BEGAN IN DECEMBER OF 2007. IN AUGUST OF 2008, THE WIRING PLUG AND RESISTOR MELTED. THE WIRING PLUG WAS REPLACED; HOWEVER, THE METAL CONNECTOR IS DEFECTIVE AND WILL NOT ALLOW THE PLUG TO PROPERLY CONNECT. AS A RESULT, THE VEHICLE CAN ONLY BE DRIVEN IN THIRD GEAR. THE DEALER STATED THAT THEY NEEDED TO DIAGNOSE THE

Mileage: 34,100

I WAS DRIVING MY 2005 GMC SIERRA 1500 TRUCK AND THE CAB FILLED WITH SMOKE THE A SMALL FIRE DEVELOPED ON THE WIRE BUNDLE THAT CONNECTS TO THE FAN BLOWER UNDER THE DASH PASSENGER SIDE. I HAD TO PULL OVER AND PRY THE BURNT CONNECTOR OFF OF THE RESISTOR / BLOWER HOOK UP. THE FUSE DID NOT WORK AND THE CONNECTOR CONTINUED TO BURN UNTIL I SHUT OFF THE TRUCK AND REMOVE THE CONNECTOR. I PLAN TO TAKE THE TRUCK INTO SKILLMAN GMC SINCE A FUSE DID NOT BLOW PRIOR TO THE BURNING OF THE WIRING. ALSO

Mileage: 43,000

TL*THE CONTACT OWNS A 2005 GMC SIERRA 1500. WHILE DRIVING AT AN UNKNOWN SPEED WITH THE HEAT ACTIVATED, THE CONTACT SMELLED SOMETHING BURNING COMING FROM THE BLOWER MOTOR. SOMETIMES, AFTER THE VEHICLE WAS DRIVEN, HE WOULD SMELL FUEL. WHEN MAKING A LEFT OR RIGHT TURN, ONE OF THE REAR TIRES SLIDES AND THE OTHER ONE KEEPS SPINNING. THE CONTACT BELIEVES THAT THE FAILURE WAS CAUSED BY THE REAR DIFFERENTIAL OR THE ABS. THE VEHICLE HAS NOT BEEN DIAGNOSED BY A DEALER OR MECHANIC AT THIS TIME. THE F

Mileage: 205

TL*THE CONTACT OWNS A 2005 GMC SIERRA 1500. WHILE DRIVING AT AN UNKNOWN SPEED WITH THE HEAT ACTIVATED, THE CONTACT SMELLED SOMETHING BURNING COMING FROM THE BLOWER MOTOR. SOMETIMES, AFTER THE VEHICLE WAS DRIVEN, HE WOULD SMELL FUEL. WHEN MAKING A LEFT OR RIGHT TURN, ONE OF THE REAR TIRES SLIDES AND THE OTHER ONE KEEPS SPINNING. THE CONTACT BELIEVES THAT THE FAILURE WAS CAUSED BY THE REAR DIFFERENTIAL OR THE ABS. THE VEHICLE HAS NOT BEEN DIAGNOSED BY A DEALER OR MECHANIC AT THIS TIME. THE F

Mileage: 205

TL*THE CONTACT OWNS A 2005 GMC SIERRA 1500. WHILE DRIVING AT AN UNKNOWN SPEED WITH THE HEAT ACTIVATED, THE CONTACT SMELLED SOMETHING BURNING COMING FROM THE BLOWER MOTOR. SOMETIMES, AFTER THE VEHICLE WAS DRIVEN, HE WOULD SMELL FUEL. WHEN MAKING A LEFT OR RIGHT TURN, ONE OF THE REAR TIRES SLIDES AND THE OTHER ONE KEEPS SPINNING. THE CONTACT BELIEVES THAT THE FAILURE WAS CAUSED BY THE REAR DIFFERENTIAL OR THE ABS. THE VEHICLE HAS NOT BEEN DIAGNOSED BY A DEALER OR MECHANIC AT THIS TIME. THE F

Mileage: 205

TL*THE CONTACT OWNS A 2005 GMC SIERRA 1500. THE CONTACT STATED THAT THE RESISTOR MELTED THE GROUNDING WIRE AND CAUSED THE BLOWER MOTOR TO FAIL. THERE IS A TECHNICAL SERVICE BULLETIN (060139002) FOR THE ENGINE AND ENGINE COOLING. THE DEALER STATED THAT THE VEHICLE WAS OUT OF WARRANTY AND THE REPAIR WOULD BE THE CONTACT'S RESPONSIBILITY. THE CURRENT MILEAGE WAS 60,670 AND FAILURE MILEAGE WAS 60,470.

Mileage: 60,470

TL*THE CONTACT OWNS A 2005 GMC SIERRA 1500. THE CONTACT STATED THAT THE RESISTOR MELTED THE GROUNDING WIRE AND CAUSED THE BLOWER MOTOR TO FAIL. THERE IS A TECHNICAL SERVICE BULLETIN (060139002) FOR THE ENGINE AND ENGINE COOLING. THE DEALER STATED THAT THE VEHICLE WAS OUT OF WARRANTY AND THE REPAIR WOULD BE THE CONTACT'S RESPONSIBILITY. THE CURRENT MILEAGE WAS 60,670 AND FAILURE MILEAGE WAS 60,470.

Mileage: 60,470

1. DRIVING ON INTERSTATE IN MY 2005 GMC SIERRA WITH MY MOTHER WHO NOTICES SMOKE COMING OUT OF THE AIR VENTS. IT WAS NOT SAFE TO OTHER VEHICLES TO PULL OVER FOR ABOUT .5 TO 1 MILE AT WHICH POINT IT WAS ALL WE COULD TO EVACUATE THE TRUCK AS IT WAS GOING UP IN FLAMES. 2. GM'S THIRD PARTY ADMINISTRATOR ESIS DENIED MY CLAIM WITHOUT EVEN CONDUCTING AN INVESTIGATION. I DID RECEIVE A LETTER FROM ESIS WITH INFORMATION ABOUT SUBMITTING A FORMAL CLAIM AGAINST GM. I NEITHER HAVE NOR CAN AFFORD AN ATTORN

Mileage: 80,000