2016 FORD F-150

SEAT BELTS:PRETENSIONER

Ford Motor Company (Ford) is recalling certain 2015-2018 Ford F-150 Regular Cab and SuperCrew Cab vehicles. If a front seat belt pretensioner deploys as the result of a crash, the sparks may ignite materials such as carpeting or insulation within the B-pillar area.

SEATS

Ford Motor Company (Ford) is recalling certain 2016 F-150 and Explorer vehicles. Loose power seat adjuster pivot bolts may cause the front seat cushions to detach and not properly restrain the seat occupant in the event of a crash.

SEAT BELTS:REAR/OTHER

Ford Motor Company (Ford) is recalling certain 2015-2017 F-150, and 2017 F-250 and F-350 trucks equipped with a crew cab. The left rear inflatable seat belt buckle assembly may be inadequately attached to its mounting bracket. As such, these vehicles fail to comply with the requirements of Federal

SEATS:FRONT ASSEMBLY:RECLINER

Ford Motor Company (Ford) is recalling certain model year 2016 Ford Explorer and F-150 vehicles equipped with a manual recline driver's seat. The seat back frame may have insufficient welds which may not meet the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restr

AIR BAGS:SENSOR:OCCUPANT CLASSIFICATION

Ford Motor Company (Ford) is recalling certain model year 2016 F-150 trucks manufactured April 27, 2015, to November 22, 2015, and equipped with Multi-Contour Seats (MCS). The front passenger seat Occupant Classification System (OCS) that calibrates the air bag deployment level may incorrectly clas

LATCHES/LOCKS/LINKAGES:DOORS:LATCH

Ford Motor Company (Ford) is recalling certain 2015-2017 F-150, and 2017 F-250, F-350, F-450, and F-550 vehicles originally produced with black or body colored exterior door handles that may have been subsequently equipped with a chrome exterior door handle cover accessory kit purchased from a Ford

ENGINE

Ford Motor Company (Ford) is recalling certain 2015-2016 F-150 pick-up trucks equipped with 3.5L GTDI engines and block immersion heaters that were potentially relocated from their originally installed location. The incorrect location could put the heater too close to hot engine components, possibl

ENGINE

Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater. Water and contaminants may get into the block heater cable's splice connector causi

LATCHES/LOCKS/LINKAGES:DOORS:LATCH

Ford Motor Company (Ford) is recalling certain 2015-2017 Ford F-150, and 2017 F-250, F-350, F-450, and F-550 Super Duty trucks. The doors on these vehicles may have a bent or kinked actuation cable or the door latches may freeze after water gets into the latch. Either condition can result in the d

SUSPENSION:FRONT:CONTROL ARM:UPPER BALL JOINT

Tenneco Automotive (DRiV) is recalling certain MOOG K500359 ball joints, for aftermarket installation on 2015-2018 Ford F-150 trucks. The ball joint may have a misaligned dust boot and may be missing alignment hole and installation warning tag, which may lead to improper alignment of the ball joint

SERVICE BRAKES, HYDRAULIC:POWER ASSIST

Ford Motor Company (Ford) is recalling certain 2016-2017 Ford Expedition, Lincoln Navigator, and 2016-2018 F-150 vehicles equipped with 3.5L Ecoboost engines. The brake master cylinder may allow brake fluid to leak from the front wheel circuit into the brake booster.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER

Ford Motor Company (Ford) is recalling certain 2014-2017 F-150 pickup trucks equipped with 3.5L Ecoboost engines. The brake master cylinder may leak brake fluid into the brake booster.

ENGINE

Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater and previously remedied under recall 18V894. During the previous repair, the block h

faulty backup camera - resulted in backing incident and tailgate damage. Reported backup camera malfunction to NHTSA in 2022 and emailed photo of camera defect, but multiple news articles about F150's being recently recalled for backup camera issued. These recalls do not include 2016 models to recall for updates and need to be added. Approximate cost of truck tailgate replacement $1500.

Sudden and without any warning, complete catastrophic brake failure while stopped attempting to pay at the pay station to exit a parking garage. My truck was fully stopped, in drive with my foot on the footbrake pedal, and started moving forward and suddenly lurched thru the parking exit gate and damaging it and the front end of my truck. Fortunately, no one was crossing on the sidewalk in front my truck or they would have been injured or worse, or we would have T-boned by oncoming traffic on

Driving out of town for a trip and out of nowhere at“Steering Assist Fail” alert hill decent alert

Driving out of town for a trip and out of nowhere at“Steering Assist Fail” alert hill decent alert

Unknown, I was pulling into a parking spot, at Sam's Club, and lightly tap the gas petal for the turn and the truck lunched forward in the one carlink, and hit a concrete parking pole (Sam's club in Southgate Michigan has security cameras) it warped around the pole and bent the frame as if though it was 90 mph and a telephone pole.. I had taken it in twice under warranty for the gas pedal not working correctly, the warranty company would not allow a 3rd repair nor did Ford dealership take that

Unknown, I was pulling into a parking spot, at Sam's Club, and lightly tap the gas petal for the turn and the truck lunched forward in the one carlink, and hit a concrete parking pole (Sam's club in Southgate Michigan has security cameras) it warped around the pole and bent the frame as if though it was 90 mph and a telephone pole.. I had taken it in twice under warranty for the gas pedal not working correctly, the warranty company would not allow a 3rd repair nor did Ford dealership take that

Unknown, I was pulling into a parking spot, at Sam's Club, and lightly tap the gas petal for the turn and the truck lunched forward in the one carlink, and hit a concrete parking pole (Sam's club in Southgate Michigan has security cameras) it warped around the pole and bent the frame as if though it was 90 mph and a telephone pole.. I had taken it in twice under warranty for the gas pedal not working correctly, the warranty company would not allow a 3rd repair nor did Ford dealership take that

The contact owns a 2016 Ford F-150. The contact stated that the rearview camera would display a distorted image while the vehicle was in reverse(R). The contact stated that the failure had obstructed the driver's visibility which prevented the driver from safely operating the vehicle. Due to the failure, the contact stated that they had been involved in two low-speed, parking lot accidents. The contact stated that no injuries were reported in either incident and that two separate police reports

Mileage: 131,142

The contact owned a 2016 Ford F-150. The contact stated while driving 40 MPH, smoke was coming from the rear passenger window with no warning lights illuminated. The contact pulled over and exited the vehicle safely and noticed that the rear of the vehicle caught on fire. The local fire department was able to extinguish the fire. The cause of the fire was undisclosed, but the fire marshal's report was provided to the contact. The contact suffered from smoke inhalation for a few days but did not

Mileage: 152,000

The contact owns a 2016 Ford F-150. The contact stated that while approaching a stop, the brake pedal was depressed, but the vehicle accelerated to unknown speeds. The driver continuously depressed the brake pedal, but it failed to respond. The driver crashed into a mailbox, brick decorations, a stop sign, a golf cart, a gas line, and a tree. The driver pulled the emergency brake, and the vehicle stopped.  There were no warning lights illuminated. The vehicle was towed to a collision center. Th

Mileage: 30,000

The contact owns a 2016 Ford F-150. The contact stated that while approaching a stop, the brake pedal was depressed, but the vehicle accelerated to unknown speeds. The driver continuously depressed the brake pedal, but it failed to respond. The driver crashed into a mailbox, brick decorations, a stop sign, a golf cart, a gas line, and a tree. The driver pulled the emergency brake, and the vehicle stopped.  There were no warning lights illuminated. The vehicle was towed to a collision center. Th

Mileage: 30,000

The contact owns a 2016 Ford F-150. The contact stated that as he was stopping the vehicle in front of his garage and slowing to approximately 3 MPH, the vehicle was not stopping. The contact stated that the brake pedal went to the floorboard when depressed. The vehicle crashed into the garage door causing the garage door to buckle. There was minor damage to the vehicle's front end. There were no injuries. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined

Mileage: 83,000

The contact owns a 2016 Ford F-150. The contact stated that while driving at 5 MPH, the contact approached a stop sign and depressed the brake pedal. However, the brake pedal was inoperable and the vehicle did not stop. Due to the brake pedal failure, the contact rear-ended the vehicle in front of him. No damage was done to either vehicle. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and advised the contact to cont

Mileage: 104,000

Today 10/23/23 I remote started my f150 and the defrost on the rear window overheated causing the glass to explode and shatter. The wires burnt to the point of smoking out and catching on fire

The contact owns a 2016 Ford F-150. The contact stated that while driving at 35 MPH, the brake pedal went to the floorboard while depressed. The vehicle failed to stop immediately rear-ending another vehicle. No air bags deployed. The contact sustained injuries to his neck and back but did not receive medical attention. A police report was filed. Additionally, the contact stated the vehicle consumed an excessive amount of oil and the key fob failed to function as needed. The vehicle was taken

Mileage: 85,000

The contact owns a 2016 Ford F-150. The contact stated that while driving at 35 MPH, the brake pedal went to the floorboard while depressed. The vehicle failed to stop immediately rear-ending another vehicle. No air bags deployed. The contact sustained injuries to his neck and back but did not receive medical attention. A police report was filed. Additionally, the contact stated the vehicle consumed an excessive amount of oil and the key fob failed to function as needed. The vehicle was taken

Mileage: 85,000

Used the remote start and came out to the truck and got in to a cab full of smoke, shut the truck off and found a electrical fire in the rear defrost system

The contact owns a 2016 Ford F-150. The contact stated that while his wife was driving, she attempted to depress the brake pedal to stop the vehicle however, the brakes failed to engage. As a result, the contact's wife rear-ended another vehicle. The air bags failed to deploy. The brake system warning light was illuminated. The contact then stated that upon inspection, he noticed brake fluid was spilled on the ground. No injuries were sustained. A police report was filed. No medical attention wa

Mileage: 87,000

The F-150 was involved in a car crash. It hit a street sign, an electrical pole and then a tree. The front bumper is split and insurance just devalued it a total loss. I am hereby reaching out to you, to let you know that none of the airbags in the truck went off. I have picture that I can provide to further confirm!

Rear window spontaneously exploded on July 8th around 11:00am. My truck was parked and not driven for two days. The rear window exploded and shattered. The glass was everywhere, In the truck bed and all over the cab. The seats and carpet have shards of glass embedded in them. I called Tom Masano Ford in Shillington PA. Spoke to Lydia a service advisor. She told me that Ford would not cover the repair/replacement of the rear window. She stated that Ford would not take any responsibility