2021 FORD E-450

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP

Ford Motor Company (Ford) is recalling certain 2021 E-350 and E-450 vehicles. A wire harness in the rear of the vehicle may contact the vehicle frame, resulting in damage to the circuits that support the fuel pump and the anti-lock braking system (ABS).

POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT

Ford Motor Company (Ford) is recalling certain 2020 F-550 and 2021 E-350 and E-450 vehicles. The rear axle differential fluid may be below the minimum level, possibly resulting in a failure of the rear axle assembly and driveshaft separation.

ENGINE

Ford Motor Company (Ford) is recalling certain 2021 E-350 and E-450 vehicles. The underside of the engine cover may have mispositioned insulation, allowing the cover to get excessively hot.

ENGINE

Ford Motor Company (Ford) is recalling certain 2021 E-350 and E-450 vehicles that received an incomplete software update under recall 20V795. The engine cover may become excessively hot.

STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS

Ford Motor Company (Ford) is recalling certain 2021-2022 E-350 and E-450 vehicles equipped with dual rear wheels. An inadequate connection between the power steering pressure line and the brake Hydroboost unit may result in a sudden loss of power steering fluid.

STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS

Ford Motor Company (Ford) is recalling certain 2021-2022 E-350 and E-450 vehicles equipped with dual rear wheels. An inadequate connection between the power steering pressure line and the brake hydroboost unit may result in a sudden loss of power steering fluid.

Airbag module casing is cracked.

Engine camshaft and lifters failed. Truck is at a Ford dealer. Engine could fail in the middle of the road, causing an accident. This is our eighth vehicle with the same issue taken to a ford dealer in the past year. A little knocking noise started that quickly turned into a loud knocking/rattling noise. No lights came on the truck.

See attached document for complaint.

See attached document for complaint.

This is one of 4 of my 2021 ford econoline fleet vehicles purchased in 2021 that have had engine failure. I am one of many contractors in my area and others around the country who have had this issue with the same F59 engine. Ford has failed to issue a recall.

Engine camshaft and lifters failed and were inspected by Ford dealer, which corrected the issue by replacing the engine. Engine can failed and truck get stuck in the middle of the road. In the past 6 months its our 4th Ford truck with the same issue and a lot of other Fedex contractors that purchased a Ford truck with the 7.3L engine are reporting the same issue. No warning light was on in this vehicle, just started with a knocking sound that got worse until it got to the dealer and engine had t

Engine Camshaft and lifters failed, unit was inspected by ford dealer and engine had to be replaced. Engine can stop working and truck could break down in the middle of the road. No warning lamps, just a loud knocking sound when brakes were applied and truck was downshifting to stop. A lot of other people that purchased these ford light duty trucks with the 7.3L engine are having the same issue.

The contact owns a 2021 Ford E-450. The contact stated while parking the vehicle, the steering wheel and brake pedal became stiff, and the vehicle failed to slow down as intended. The contact stated that the brake pedal was continuously depressed for the vehicle to come to a stop. The vehicle was towed to an independent mechanic where it was diagnosed that the power steering hose and fluids needed to be flushed and refilled. The vehicle was repaired. The manufacturer was not notified of the fail

Mileage: 14,104

The contact owns a 2021 Ford E-450. The contact stated while parking the vehicle, the steering wheel and brake pedal became stiff, and the vehicle failed to slow down as intended. The contact stated that the brake pedal was continuously depressed for the vehicle to come to a stop. The vehicle was towed to an independent mechanic where it was diagnosed that the power steering hose and fluids needed to be flushed and refilled. The vehicle was repaired. The manufacturer was not notified of the fail

Mileage: 14,104

Component= Traction control and cruise control. Safety risk=Driving a Ford e-450 Class C RV on interstate at 63 MPH going generally up hill with cruise control on, the "Service AdvanceTrac" warning light came on dashboard. I Immediately lost cruise control capability and steering became a little shakey. Pulled into rest area shut vehicle off. A few minutes and started again. Error went away and cruise control was functioning. Happened again a few hours later and I did the same thing and continue

Component= Traction control and cruise control. Safety risk=Driving a Ford e-450 Class C RV on interstate at 63 MPH going generally up hill with cruise control on, the "Service AdvanceTrac" warning light came on dashboard. I Immediately lost cruise control capability and steering became a little shakey. Pulled into rest area shut vehicle off. A few minutes and started again. Error went away and cruise control was functioning. Happened again a few hours later and I did the same thing and continue

My RV is make from 2021 Ford E-450. The power steering fluid leaked out and hard to steer the RV, and lost break. Ford has a recall 2021E-450 under similar situation, but my Vin did not received any recall notice.

My RV is make from 2021 Ford E-450. The power steering fluid leaked out and hard to steer the RV, and lost break. Ford has a recall 2021E-450 under similar situation, but my Vin did not received any recall notice.

The contact owns a 2021 Jayco Redhawk Motorhome built on a 2021 Ford E-450 chassis. The contact stated that while her friend was driving at an undisclosed speed, the brake pedal was depressed and went to the floorboard. The RV was towed to the dealer, who informed the contact that the brake line had deteriorated and needed to be replaced. The RV was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 23,000.

Mileage: 23,000

2021 FORD E-450- Recall# 21V-441- heat shield not properly installed in between the LP tank and chassis muffler. Consumer enclosed a copy of the recall notice. Consumer went to an RV dealer in reference to a recall repair. The dealership made a call and informed consumer it could be fixed & would received return phone call that same evening or the next day. Several days passed. Consumer called representative 2 more times within a 3 week period with no return call. Consumer called a 3rd time & re

2021 FORD E-450- Recall# 21V-441- heat shield not properly installed in between the LP tank and chassis muffler. Consumer enclosed a copy of the recall notice. Consumer went to an RV dealer in reference to a recall repair. The dealership made a call and informed consumer it could be fixed & would received return phone call that same evening or the next day. Several days passed. Consumer called representative 2 more times within a 3 week period with no return call. Consumer called a 3rd time & re

The contact owns a 2021 Phoenix Cruiser RV built on a 2021 Ford E-450 chassis, equipped with a 6400 Series window vent. The contact stated that he became aware that the side window was delaminating. The contact became aware of NHTSA Campaign Number: 21E047000 (Structure, Equipment). The RV was taken to a local dealer and was diagnosed, and it was determined that the failure was related to the adhesive; however, no repairs were completed. The manufacturer was made aware of the failure. The failur

The contact owns a 2021 Phoenix Cruiser RV built on a 2021 Ford E-450 chassis, equipped with a 6400 Series window vent. The contact stated that he became aware that the side window was delaminating. The contact became aware of NHTSA Campaign Number: 21E047000 (Structure, Equipment). The RV was taken to a local dealer and was diagnosed, and it was determined that the failure was related to the adhesive; however, no repairs were completed. The manufacturer was made aware of the failure. The failur

We received the two recall notice letters from Ford Motor Company, 20V795 & 22V089, for our 2021 Jayco Redhawk class C RV. Upon receiving the first recall notice, 20V795, an appointment was made with our local Ford Dealer, Spradley Ford Lincoln Mercury, in Pueblo, CO, on Oct 1, 2021 to have it inspected and recall taken care of. Upon arrival that morning, was told they did not have the parts, would have to order them & their technician just called in "sick". Appointment was rescheduled once they

We received the two recall notice letters from Ford Motor Company, 20V795 & 22V089, for our 2021 Jayco Redhawk class C RV. Upon receiving the first recall notice, 20V795, an appointment was made with our local Ford Dealer, Spradley Ford Lincoln Mercury, in Pueblo, CO, on Oct 1, 2021 to have it inspected and recall taken care of. Upon arrival that morning, was told they did not have the parts, would have to order them & their technician just called in "sick". Appointment was rescheduled once they