2004 DODGE CARAVAN

EQUIPMENT

AFTERMARKET REPLACEMENT FUEL FILTERS MANUFACTURED BETWEEN SEPTEMBER 17, 2002, AND JANUARY 20, 2003, SOLD UNDER THE BRAND NAMES LISTED ABOVE. THE FILTER MAY EXPERIENCE MALFUNCTION OF THE QUICK CONNECTOR EITHER BLOCKING FUEL FLOW TO THE ENGINE OR CAUSING A FUEL LEAK. THIS DOES NOT INVOLVE ANY PRODU

FUEL SYSTEM, GASOLINE

CERTAIN AFTERMARKET REPLACEMENT FUEL FILTERS, MODELS WIX FILTER PART NUMBERS 33576, 33577, 33734; NAPA FILTER PART NUMBERS 3576, 3577, 3734; AND CARQUEST FILTER PART NUMBERS 86576, 86577, 86734 USED ON 1996-2000 DAIMLERCHRYSLER TOWN & COUNTRY, DODGE CARAVAN, AND PLYMOUTH VOYAGER VEHICLES, CAN CAUSE

SERVICE BRAKES, HYDRAULIC

CERTAIN AFTERMARKET BRAKE HYDRAULIC MASTER CYLINDERS SOLD AS REPLACEMENT BRAKE CYLINDERS FOR CERTAIN FORD, DAIMLERCHRYSLER, AND JEEP PASSENGER VEHICLES. THESE BRAKE CYLINDERS WERE SOLD UNDER THE BRAND NAMES OF NAPA, RAYBESTOS, AIMCO, AC DELCO, CARQUEST, BENDIX, AND WAGNER. ONLY PRODUCTS THAT WERE

VISIBILITY:GLASS, SIDE/REAR

CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS LTD AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., IDENTIFIED AS DOT-430, AND SOLD FOR USE ON CERTAIN DOMESTIC AND FOREIGN VEHICLES MAY NOT BREAK INTO SMALL PIECES AS EXPECTED OF TEMPERED GLASS AND FAILS TO CONFORM TO FEDER

EQUIPMENT

CURT MFG IS RECALLING CERTAIN CLASS 3 RECEIVER HITCHES, P/N 13347, SOLD AS AFTERMARKET EQUIPMENT FOR USE ON 1997-2007 CHRYSLER TOWN AND COUNTRY VANS, 1996-2007 DODGE CARAVANS, AND 1996-2004 PLYMOUTH VOYAGER VANS. WHEN THE HITCH IS LOADED TO THE MAXIMUM RATING, THE HITCH MAY FRACTURE OR BREAK AT THE

EXTERIOR LIGHTING:HEADLIGHTS

MAXZONE IS RECALLING 2,520 HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 3341103L-AS AND 334-1103R-AS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR 2001-2007 DODGE CARAVAN PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLEC

EXTERIOR LIGHTING:HEADLIGHTS

EAGLE EYES IS RECALLING 11,534 HEADLAMP ASSEMBLIES, P/NOS. CS090-B001L AND CS090-B001R, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE LOWER BEAM PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS,

STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS

ON CERTAIN MINIVANS EQUIPPED WITH 3.3 OR 3.8L V-6 ENGINE, THE UPPER POWER STEERING COOLER HOSE MAY SPLIT AND CAUSE A FLUID LEAK.

AS I WENT TO STOP THE FRONT WHEELS SLID LIKE THEY WERE ON ICE. I WAS ON A PUBLIC RD. [BLACK TOP] I HIT THE CAR IN FRONT OF ME.

Mileage: 105,000

I ORIGINALLY FILED A COMPLAINT AGAINST THE PAD MANUFACTURER BUT IT SEEMS TO BE THE COMPOSITE PISTON IN THE CALIPER THAT IS INTERMITTENTLY CAUSING THE BRAKES TO OVERHEAT. THE PEDAL TRAVEL GOES TO ZERO AND THE BRAKE IS LOCKED. THIS IS A MANUFACTURES DEFECT AND A HAZARD. IT WOULD BE EASY FOR THESE BRAKES TO FAIL IN HIGHWAY CONDITIONS AND HAVE THE GREASE MELT OUT OF THE BEARINGS FROM THE HEAT AND BRAKE FLUID TO BOIL. THIS CAR HAS BEEN GARAGED ITS ENTIRE LIFE AND MAINTAINED. IT IS CHRYSLER THAT IN TH

Mileage: 60,000

I REPLACED THE BRAKES ON MY 2004 DODGE CARAVAN WITH DURALAST BRAKES FROM AUTO ZONE. THERE IS A SEVERE PROBLEM WITH THE TOLERANCES ON THE PADS. I HAVE BEEN INSTALLING BRAKES FOR 50 YEARS. THERE IS A SEVER DEFECT WITH THESE REPLACEMENT PARTS. THE PADS WILL NOT ALLOW THE CALIPER TO RETRACT THE PADS WEDGE AGAINST THE ROTOR-DISC. THEY CAUSED A VEHICLE FIRE FROM THE EXTREME HEAT. I CONTACTED AUTO ZONE AND INSTALLED ANOTHER SET . THIS TIME IT CAUSED THE BRAKE ON THE OPPOSITE SIDE TO OVERHEAT. I GOT A

TL*THE CONTACT OWNS A 2004 DODGE CARAVAN. WHILE DRIVING 35 MPH, THE STEERING WHEEL BECAME VERY DIFFICULT TO TURN. THE VEHICLE ALSO BEGAN TO JERK BACK AND FORTH. THE CONTACT ALSO NOTICED THAT THE DIAL FOR THE OUTSIDE TEMPERATURE GAUGE WAS EXTREMELY HIGH. THE CONTACT PULLED THE VEHICLE TO THE SIDE OF THE ROAD AND NOTICED THAT THE PASSENGER SIDE WHEEL WAS ON FIRE. HE WAS ABLE TO EXTINGUISH THE FIRE WITHOUT INJURIES. THE VEHICLE WAS TOWED TO THE DEALER AND HAS NOT BEEN DIAGNOSED. THE VIN WAS

Mileage: 73,000

TL*THE CONTACT OWNS A 2004 DODGE CARAVAN. WHILE DRIVING 35 MPH, THE STEERING WHEEL BECAME VERY DIFFICULT TO TURN. THE VEHICLE ALSO BEGAN TO JERK BACK AND FORTH. THE CONTACT ALSO NOTICED THAT THE DIAL FOR THE OUTSIDE TEMPERATURE GAUGE WAS EXTREMELY HIGH. THE CONTACT PULLED THE VEHICLE TO THE SIDE OF THE ROAD AND NOTICED THAT THE PASSENGER SIDE WHEEL WAS ON FIRE. HE WAS ABLE TO EXTINGUISH THE FIRE WITHOUT INJURIES. THE VEHICLE WAS TOWED TO THE DEALER AND HAS NOT BEEN DIAGNOSED. THE VIN WAS

Mileage: 73,000

THE BRAKES FAILED AT 55 MPH. THIS CAUSED EXTENDED STOPPING DISTANCE, AND VEHICLE RAN OFF THE ROAD. CONSUMER SUFFERED MINOR INJURIES. THE VEHICLE WAS TOWED. THE DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM.*AK THE CONSUMER STATED THAT THE VEHICLE WAS TOTALED IN A ROLLOVER FOLLOWING BRAKE FAILURE. NO AIR BAG WAS DEPLOYED. *TC

THE BRAKES FAILED AT 55 MPH. THIS CAUSED EXTENDED STOPPING DISTANCE, AND VEHICLE RAN OFF THE ROAD. CONSUMER SUFFERED MINOR INJURIES. THE VEHICLE WAS TOWED. THE DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM.*AK THE CONSUMER STATED THAT THE VEHICLE WAS TOTALED IN A ROLLOVER FOLLOWING BRAKE FAILURE. NO AIR BAG WAS DEPLOYED. *TC

WHILE DRIVING AT 25 MPH LATCH MECHANISM WAS NOT LOCKED PROPERLY. AS A RESULT THE BENCH SEAT MOVED FORWARD, AND CHILD WHO WAS SEATED HIT HIS FACE ON THE BACK OF THE PASSENGER SIDE . MANUFACTURER AND DEALERSHIP HAD BEEN NOTIFIED. *AK