2001 DODGE CARAVAN

LATCHES/LOCKS/LINKAGES:DOORS:LATCH

THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 2001 PLYMOUTH VOYAGER, CHRYSLER TOWN & COUNTRY, AND DODGE CARAVAN/GRAND CARAVAN MINI VANS THAT ARE NOT EQUIPPED WITH THE REMOTE KEYLESS ENTRY OP

EQUIPMENT

AFTERMARKET REPLACEMENT FUEL FILTERS MANUFACTURED BETWEEN SEPTEMBER 17, 2002, AND JANUARY 20, 2003, SOLD UNDER THE BRAND NAMES LISTED ABOVE. THE FILTER MAY EXPERIENCE MALFUNCTION OF THE QUICK CONNECTOR EITHER BLOCKING FUEL FLOW TO THE ENGINE OR CAUSING A FUEL LEAK. THIS DOES NOT INVOLVE ANY PRODU

FUEL SYSTEM, GASOLINE

CERTAIN AFTERMARKET REPLACEMENT FUEL FILTERS, MODELS WIX FILTER PART NUMBERS 33576, 33577, 33734; NAPA FILTER PART NUMBERS 3576, 3577, 3734; AND CARQUEST FILTER PART NUMBERS 86576, 86577, 86734 USED ON 1996-2000 DAIMLERCHRYSLER TOWN & COUNTRY, DODGE CARAVAN, AND PLYMOUTH VOYAGER VEHICLES, CAN CAUSE

SERVICE BRAKES, HYDRAULIC

CERTAIN AFTERMARKET BRAKE HYDRAULIC MASTER CYLINDERS SOLD AS REPLACEMENT BRAKE CYLINDERS FOR CERTAIN FORD, DAIMLERCHRYSLER, AND JEEP PASSENGER VEHICLES. THESE BRAKE CYLINDERS WERE SOLD UNDER THE BRAND NAMES OF NAPA, RAYBESTOS, AIMCO, AC DELCO, CARQUEST, BENDIX, AND WAGNER. ONLY PRODUCTS THAT WERE

EQUIPMENT

CURT MFG IS RECALLING CERTAIN CLASS 3 RECEIVER HITCHES, P/N 13347, SOLD AS AFTERMARKET EQUIPMENT FOR USE ON 1997-2007 CHRYSLER TOWN AND COUNTRY VANS, 1996-2007 DODGE CARAVANS, AND 1996-2004 PLYMOUTH VOYAGER VANS. WHEN THE HITCH IS LOADED TO THE MAXIMUM RATING, THE HITCH MAY FRACTURE OR BREAK AT THE

EXTERIOR LIGHTING:HEADLIGHTS

MAXZONE IS RECALLING 2,520 HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 3341103L-AS AND 334-1103R-AS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR 2001-2007 DODGE CARAVAN PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLEC

EXTERIOR LIGHTING:HEADLIGHTS

EAGLE EYES IS RECALLING 11,534 HEADLAMP ASSEMBLIES, P/NOS. CS090-B001L AND CS090-B001R, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE LOWER BEAM PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS,

SUSPENSION:FRONT:CONTROL ARM:LOWER ARM

VEHICLE DESCRIPTION: MINIVANS. THE LOWER CONTROL ARM PIVOT BOLT COULD FRACTURE.

STRUCTURE

CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EX

EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

ON CERTAIN MINI VANS, CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DROP THROUGH VENT HOLES IN THE TOP OF THE RADIO AND RESULT IN A SHORT CIRCUIT THAT SUBSEQUENTLY SENDS DIRECT CURRENT TO THE REAR SPEAKERS.

TL* THE CONTACT OWNS A 2001 DODGE CARAVAN SPORT. WHILE ATTEMPTING TO MAKE A LEFT TURN, THE STEERING WHEEL SUDDENLY LOCKED AND CAUSING THE STEERING WHEEL TO MAKE A POPPING NOISE. THE STEERING WHEEL BECAME DIFFICULT TO TURN. THE CONTACT HAD TO USE EXCESSIVE FORCE TO MOVE THE STEERING WHEEL. SUDDENLY, THE STEERING WHEEL DID A HARD RELEASE AND RETURNED TO NORMAL. THE HARD RELEASE CAUSED THE CONTACT TO RECEIVE INJURIES TO THE HAND, WRIST, AND ARM. MEDICAL ATTENTION WAS NEEDED. THE FAILURE RECURRED. T

Mileage: 102,000

TL* THE CONTACT OWNED A 2001 DODGE CARAVAN. WHILE DRIVING 70 MPH, THE VEHICLE VEERED OFF THE ROAD AND CRASHED INTO A TREE. THE AIR BAGS DEPLOYED. THE SECOND ROW DRIVER'S SIDE SEAT BELT FRACTURED. THE CONTACT SUSTAINED INJURIES TO THE HEAD, CHEST, AND ANKLE. THE FRONT PASSENGER RECEIVED A SPRAINED ANKLE AND THE OTHER OCCUPANT RECEIVED A BROKEN WRIST, BROKEN STERNUM, AND A CRACKED PELVIS/HIP. MEDICAL ATTENTION WAS REQUIRED. A POLICE REPORT WAS FILED. THE VEHICLE WAS DESTROYED AND TOWED. THE MANUFA

PULLED VEHICLE OUT OF GARAGE AND SHORTLY AFTER FIRE STARTED TO COME UP OUT OF THE DASH. COMPLETE LOSS. CALLED FIRE DEPARTMENT TO TRY TO PUT THE FIRE OUT BUT IT SPREAD IN A MATTER OF MINUTES.. THIS WAS NOT MY CAR BUT MY MOTHER IN LAWS. *TR

Mileage: 115,000

PULLED VEHICLE OUT OF GARAGE AND SHORTLY AFTER FIRE STARTED TO COME UP OUT OF THE DASH. COMPLETE LOSS. CALLED FIRE DEPARTMENT TO TRY TO PUT THE FIRE OUT BUT IT SPREAD IN A MATTER OF MINUTES.. THIS WAS NOT MY CAR BUT MY MOTHER IN LAWS. *TR

Mileage: 115,000

PULLED VEHICLE OUT OF GARAGE AND SHORTLY AFTER FIRE STARTED TO COME UP OUT OF THE DASH. COMPLETE LOSS. CALLED FIRE DEPARTMENT TO TRY TO PUT THE FIRE OUT BUT IT SPREAD IN A MATTER OF MINUTES.. THIS WAS NOT MY CAR BUT MY MOTHER IN LAWS. *TR

Mileage: 115,000

GOT REAR ENDED AND SEAT BROKE SENDING DRIVER ACROSS VAN WITH SEAT BELT IN TAC. *TR

Mileage: 356,000

HERE'S A DEAD GUY FROM A BAD DODGE CARAVAN CLOCKSPRING THAT YOU REFUSE TO RECALL BEYONG FY2000. WHAT IS IT YOU GOVERNMENT GALLOOFS DO ALL DAY? NEW YORK - A FAMED STRONGMAN WHO ONCE LIFTED 3,200 POUNDS AT CONEY ISLAND DURING ITS HEYDAY AND WAS STILL BENDING QUARTERS WITH HIS FINGERS AT AGE 104 DIED MONDAY AFTER HE WAS HIT BY A MINIVAN. JOE ROLLINO WAS STRUCK AS HE CROSSED A MAJOR STREET IN BROOKLYN, AND SUFFERED A BROKEN PELVIS, HEAD TRAUMA AND BROKEN RIBS. HE DIED A FEW HOURS LATER AT AN

HERE'S A DEAD GUY FROM A BAD DODGE CARAVAN CLOCKSPRING THAT YOU REFUSE TO RECALL BEYONG FY2000. WHAT IS IT YOU GOVERNMENT GALLOOFS DO ALL DAY? NEW YORK - A FAMED STRONGMAN WHO ONCE LIFTED 3,200 POUNDS AT CONEY ISLAND DURING ITS HEYDAY AND WAS STILL BENDING QUARTERS WITH HIS FINGERS AT AGE 104 DIED MONDAY AFTER HE WAS HIT BY A MINIVAN. JOE ROLLINO WAS STRUCK AS HE CROSSED A MAJOR STREET IN BROOKLYN, AND SUFFERED A BROKEN PELVIS, HEAD TRAUMA AND BROKEN RIBS. HE DIED A FEW HOURS LATER AT AN

THE RIGHT SIDE WHEEL BROKE OFF OF THE A FRAME CAUSING ME TO CRASH INTO GUARD RAIL NOT FOR GUARD RAIL GRAND KIDS COULD HAVE BEEN HURT BAD OR EVEN KILLED. *TR

Mileage: 63,547

I BOUGHT A BRAND NEW 2001 DODGE CARAVAN SE AND HAD ENGINE & ELECTRICAL PROBLEMS. JUST A FEW MONTHS LATER, WHILE DRIVING OVER THE BRIDGE OUT OF NEW YORK CITY, THE CAR FILLED UP WITH WHITE SMOKE OF A REALLY TOXIC SMELL. GREENISH BROWN FLUID LEAKED OUT AT MY FEET. SEVERAL TIMES I WENT TO HAVE IT FIXED, ALL THE FLUIDS WOULD LEAK OUT OF THE BOTTOM OF THE CAR, I WOULD TAKE IT BACK TO ONLY HAVE IT HAPPEN AGAIN. FINALLY THEY CLAMPED A HOSE UNDERNEATH THE CAR CAUSING FLUIDS TO SWISH BACK AND FORTH IN T

I BOUGHT A BRAND NEW 2001 DODGE CARAVAN SE AND HAD ENGINE & ELECTRICAL PROBLEMS. JUST A FEW MONTHS LATER, WHILE DRIVING OVER THE BRIDGE OUT OF NEW YORK CITY, THE CAR FILLED UP WITH WHITE SMOKE OF A REALLY TOXIC SMELL. GREENISH BROWN FLUID LEAKED OUT AT MY FEET. SEVERAL TIMES I WENT TO HAVE IT FIXED, ALL THE FLUIDS WOULD LEAK OUT OF THE BOTTOM OF THE CAR, I WOULD TAKE IT BACK TO ONLY HAVE IT HAPPEN AGAIN. FINALLY THEY CLAMPED A HOSE UNDERNEATH THE CAR CAUSING FLUIDS TO SWISH BACK AND FORTH IN T

2001 DODGE CARAVAN REAR SHOULDER STRAPS WILL NOT CATCH IN CRASH, FRONT BELTS WORKED FINE BUT ALL OF REAR SEAT BELTS WILL NOT CATCH IF YOU JERK ON THEM YOU CAN SEE THEY DON'T CATCH AND THEY DID NOT CATCH MY DAUGHTER AND SHE WAS BADLY INJURED. *NM UPDATED 03/31/06. *JB

WHILE DRIVING VEHICLE HIT AN ICE PATCH IN THE ROAD. THE ANTI LOCK BRAKES FAILED, AND VEHICLE SPUN AROUND, AND WENT INTO A RAVINE. WHILE GOING DOWN, CONSUMER HIT A TREE WHICH STOPPED THE VEHICLE. DRIVER'S SEAT BACK RECLINED, LAYING THE CONSUMER COMPLETELY DOWN. SOMEHOW SHE THEN SLID OUT OF THE SEAT BELT, AND LANDED IN THE BACK SEAT WITH THE SEAT BELT STILL ENGAGED. *AK SINCE THE ACCIDENT CONSUMER'S SHOULDER/NECK, AND HEAD ARE IN CONSTANT PAIN.DIFFICULTY FOCUSING, AN DIS UNABLE TO DRIVE FOR LONG

Mileage: 52,102

OWNED A 2001 DODGE CARAVAN THAT CAUGHT ON FIRE. FIRE CAME FROM UNDERNEATH THE MIDDLE OF THE DASH BOARD IN THE CENTER. THE CAR WAS TOTALED AS WELL AS MY OTHER CAR AND GARAGE DOOR. *JB

SEAT BACK ON THE CAPTAINS CHAIR LOCATED ON REAR DRIVER'S SIDE DID NOT LOCK IN PLACE, RESULTING IN CHILD BEING INJURED. CHILD SUSTAINED A BLACKENED EYE FROM HITTING THE DRIVER'S SEAT. *AK CONSUMER STATED THAT REAR SEAT DIDN'T LATCHED PROPERLY CAUSING THE SEAT TO PIVOT FORWARD. BROUGHT SEAT TO THE DEALER AND FOUND THAT THE MECHANISM THAT LOCKS CHAIR WAS FROZEN. *LA

Mileage: 41,000

IN THE 3RD ROW OF SEATS IN MY 2001 DODGE MINIVAN, A PASSENGER LEFT THE SEATBACK IN A SEMI-RECLINED POSITION. I LEANED IN TO RELEASE THE SEATBACK TO FULL UPRIGHT. WHEN I ENGAGED THE RELEASE, THE SEATBACK SNAPPED FORWARD WITH GREAT SPEED AND FORCE ALL THE WAY DOWN UNTIL IT RESTED ON THE SEAT. IN ITS PATH DOWNWARD, IT FAILED TO STOP IN THE UPRIGHT POSITION. THE TOP OF THE SEAT STRUCK FULL IN MY FACE, BREAKING MY GLASSES, CAUSING A BRUISE AND ABRASION TO MY NOSE. IN SUBSEQUENT TESTS, THE SEATB

Mileage: 15,568

WHEN THE BRAKES WERE APPLIED, THE VEHICLE EXPERIENCED EXTENDED STOPPING DISTANCE. *JB

THE CONSUMER WAS MAKING A LEFT TURN, AND A SEMI TRAILER HIT THE CONSUMER. THE VEHICLE ROLLED OVER AND NONE OF THE FRONT OF SIDE AIR BAGS DEPLOYED. TS SCC

Mileage: 9,600

CONSUMER STATES WHILE COMING DOWN RAMP, THE DOOR FRAME HAS A PIECE OF METAL THAT STICKS OUT, CONSUMERS CLOTHING GOT CAUGHT ON METAL AND ARM WAS MUTALATED AND FRACTURED. CONSUMER FEELS THIS PIECE OF METAL IS VERY UNSAFE. PLEASE PROVIDE ANY FURTHER INFORMATION.*JB

MR.GERALD LOTTO IS AN ATTORNEY ON BEHALF OF SHERRI CAPONE STATING THAT AIR BAGS DID NOT DEPLOY DURING A COLLISION. THERE WAS DAMAGE TO THE FRONT OF THE VEHICLE AND MS. CAPONE SUSTAINED EXTENSIVE FACIAL INJURIES. *TT