2000 DODGE CARAVAN

EQUIPMENT

AFTERMARKET REPLACEMENT FUEL FILTERS MANUFACTURED BETWEEN SEPTEMBER 17, 2002, AND JANUARY 20, 2003, SOLD UNDER THE BRAND NAMES LISTED ABOVE. THE FILTER MAY EXPERIENCE MALFUNCTION OF THE QUICK CONNECTOR EITHER BLOCKING FUEL FLOW TO THE ENGINE OR CAUSING A FUEL LEAK. THIS DOES NOT INVOLVE ANY PRODU

FUEL SYSTEM, GASOLINE

CERTAIN AFTERMARKET REPLACEMENT FUEL FILTERS, MODELS WIX FILTER PART NUMBERS 33576, 33577, 33734; NAPA FILTER PART NUMBERS 3576, 3577, 3734; AND CARQUEST FILTER PART NUMBERS 86576, 86577, 86734 USED ON 1996-2000 DAIMLERCHRYSLER TOWN & COUNTRY, DODGE CARAVAN, AND PLYMOUTH VOYAGER VEHICLES, CAN CAUSE

FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM

VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.

SERVICE BRAKES, HYDRAULIC

CERTAIN AFTERMARKET BRAKE HYDRAULIC MASTER CYLINDERS SOLD AS REPLACEMENT BRAKE CYLINDERS FOR CERTAIN FORD, DAIMLERCHRYSLER, AND JEEP PASSENGER VEHICLES. THESE BRAKE CYLINDERS WERE SOLD UNDER THE BRAND NAMES OF NAPA, RAYBESTOS, AIMCO, AC DELCO, CARQUEST, BENDIX, AND WAGNER. ONLY PRODUCTS THAT WERE

EXTERIOR LIGHTING:HEADLIGHTS

CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPME

VISIBILITY:GLASS, SIDE/REAR

CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS LTD AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., IDENTIFIED AS DOT-430, AND SOLD FOR USE ON CERTAIN DOMESTIC AND FOREIGN VEHICLES MAY NOT BREAK INTO SMALL PIECES AS EXPECTED OF TEMPERED GLASS AND FAILS TO CONFORM TO FEDER

EXTERIOR LIGHTING:HEADLIGHTS

DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES

EQUIPMENT:OTHER:LABELS

ON CERTAIN MINIVANS AND 4X2 PICKUP TRUCKS, THE VEHICLE CERTIFICATION LABEL MAY HAVE GROSS AXLE WEIGHT RATINGS (GAWR) THAT EXCEED THE MAXIMUM TIRE LOAD CAPACITY AS DEFINED IN FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."

EQUIPMENT

CURT MFG IS RECALLING CERTAIN CLASS 3 RECEIVER HITCHES, P/N 13347, SOLD AS AFTERMARKET EQUIPMENT FOR USE ON 1997-2007 CHRYSLER TOWN AND COUNTRY VANS, 1996-2007 DODGE CARAVANS, AND 1996-2004 PLYMOUTH VOYAGER VANS. WHEN THE HITCH IS LOADED TO THE MAXIMUM RATING, THE HITCH MAY FRACTURE OR BREAK AT THE

EXTERIOR LIGHTING

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES

STRUCTURE

CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EX

AIR BAGS

ON CERTAIN MINIVANS, THE DRIVER'S AIR BAG MAY BECOME DISABLED DUE TO A FAILURE OF THE CLOCKSPRING, WHICH IS LOCATED IN THE HUB OF THE STEERING WHEEL.

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

CERTAIN AIRTEX FUEL PUMP MODULES, P/NOS. E7089M, E7094M, E7113M, AND E7129M, MANUFACTURED BETWEEN JUNE 1 AND SEPTEMBER 24, 2006. THESE FUEL PUMP MODULES WERE SOLD AS AFTERMARKET FOR USE IN CERTAIN DAIMLERCHRYSLER VEHICLES LISTED ABOVE. SILICONE MATERIAL USED IN MANUFACTURE OF THE FLAPPER VALVE WAS

VEHICLE WAS IN MOTION- WHILE DRIVING ALONG I HEARD AND FELT A LOUD NOISE (BOOM) FROM REAR OF VEHICLE-VEHICLE THEN SWERVED WILDLY OUT OF CONTROL SPINNING AROUND AND TAKING DOWN SIGNS, MAILBOX-AFTER LOOKING AT VAN IT IS APPARENT THAT THE REAR AXLE SLID BACKWARDS IN WHEEL WELL. WHILE BODY IS RUST FREE, UNDERCARRIAGE HAS EXCESSIVE RUST IN SPRING HANGER AREA-VAN HAS BEEN PARKED ON PAVEMENT ITS ENTIRE LIFE.

Mileage: 65,000

VEHICLE WAS IN MOTION- WHILE DRIVING ALONG I HEARD AND FELT A LOUD NOISE (BOOM) FROM REAR OF VEHICLE-VEHICLE THEN SWERVED WILDLY OUT OF CONTROL SPINNING AROUND AND TAKING DOWN SIGNS, MAILBOX-AFTER LOOKING AT VAN IT IS APPARENT THAT THE REAR AXLE SLID BACKWARDS IN WHEEL WELL. WHILE BODY IS RUST FREE, UNDERCARRIAGE HAS EXCESSIVE RUST IN SPRING HANGER AREA-VAN HAS BEEN PARKED ON PAVEMENT ITS ENTIRE LIFE.

Mileage: 65,000

TL* THE CONTACT OWNS A 2000 DODGE CARAVAN. WHILE DRIVING APPROXIMATELY 35 MPH, ANOTHER VEHICLE COLLIDED WITH THE CONTACT'S VEHICLE. THE CONTACT STATED THAT THE VEHICLE DID NOT HAVE AIR BAGS AND THE HORN MALFUNCTIONED. THE CONTACT RECEIVED INJURIES TO THE LEFT SHOULDER, NECK, BACK, AND HEAD THAT REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO AN AUTO MECHANIC FACILITY WITH PENDING DIAGNOSTIC RESULTS. THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS UNKNOWN. THE FAILU

Mileage: 296,000

TL* THE CONTACT OWNS A 2000 DODGE CARAVAN. WHILE DRIVING APPROXIMATELY 35 MPH, ANOTHER VEHICLE COLLIDED WITH THE CONTACT'S VEHICLE. THE CONTACT STATED THAT THE VEHICLE DID NOT HAVE AIR BAGS AND THE HORN MALFUNCTIONED. THE CONTACT RECEIVED INJURIES TO THE LEFT SHOULDER, NECK, BACK, AND HEAD THAT REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO AN AUTO MECHANIC FACILITY WITH PENDING DIAGNOSTIC RESULTS. THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS UNKNOWN. THE FAILU

Mileage: 296,000

9/8/2008 I WAS TRAVELING ON IR80 & I MUST OF SWERVED A BIT & THE VAN STRUCK A DOT PADDLE MARKER @ HUMBOLDT MILE MARKER 45 IN NEVADA. THE VAN BECAME ENGULFED IN FLAMES & OVERTURNED SIDEWAYS AT LEAST 4 TIMES. MY MOTHER & FATHER PARRISHED AS A RESULT OF THIS ACCIDENT, BURNED SO MUCH THEY COULDN'T RECOGNIZE THEIR GENDER. MY WIFE & I ESCAPED WITH HER GETTING SEVERELY BURNED ABOUT 76% & I ABOUT 68%, WE WAS TRANSPORTED TO HUMBOLTD HOSPITAL THEN AIR TRANSPORTED TO U OF U BURN CENTER SALT LAKE CITY UTAH

Mileage: 97,000

9/8/2008 I WAS TRAVELING ON IR80 & I MUST OF SWERVED A BIT & THE VAN STRUCK A DOT PADDLE MARKER @ HUMBOLDT MILE MARKER 45 IN NEVADA. THE VAN BECAME ENGULFED IN FLAMES & OVERTURNED SIDEWAYS AT LEAST 4 TIMES. MY MOTHER & FATHER PARRISHED AS A RESULT OF THIS ACCIDENT, BURNED SO MUCH THEY COULDN'T RECOGNIZE THEIR GENDER. MY WIFE & I ESCAPED WITH HER GETTING SEVERELY BURNED ABOUT 76% & I ABOUT 68%, WE WAS TRANSPORTED TO HUMBOLTD HOSPITAL THEN AIR TRANSPORTED TO U OF U BURN CENTER SALT LAKE CITY UTAH

Mileage: 97,000

9/8/2008 I WAS TRAVELING ON IR80 & I MUST OF SWERVED A BIT & THE VAN STRUCK A DOT PADDLE MARKER @ HUMBOLDT MILE MARKER 45 IN NEVADA. THE VAN BECAME ENGULFED IN FLAMES & OVERTURNED SIDEWAYS AT LEAST 4 TIMES. MY MOTHER & FATHER PARRISHED AS A RESULT OF THIS ACCIDENT, BURNED SO MUCH THEY COULDN'T RECOGNIZE THEIR GENDER. MY WIFE & I ESCAPED WITH HER GETTING SEVERELY BURNED ABOUT 76% & I ABOUT 68%, WE WAS TRANSPORTED TO HUMBOLTD HOSPITAL THEN AIR TRANSPORTED TO U OF U BURN CENTER SALT LAKE CITY UTAH

Mileage: 97,000

***BLF NOTE CALL CONSUMER TO GET MORE INFO*** MY MOTHER BOUGHT BRAND NEW MIN VAN FROM DODGE, SHE HAS FOR 8 MONTHS. SHE DROVE IN COUNTY ROAD. SHE HIT POTHOLE IN 40 MPH THEN AIR BAG BLEW UP. SHE NOT ABLE TO SEE ROAD WHEN AIR BAD BLOW UP, THAT CAUSE VAN RUN OFF RIGHT SIDE SHOULDER. COUNTY ROAD HAVE A LOT CURE. VAN HAS NOT HIT TILL, SHE CAN NOT SEE ROAD AND WHEEL GO STAY STRAIGHT WHILE ROAD IS CURE. SHE HAVE CLAIM TO DODGE TWICE AND STILL DENY. SHE LOST EVERYTHING. I GAVE HER MY OLD TRUCK FOR HER

Mileage: 100

TL* THE CONTACT OWNS A 2000 DODGE CARAVAN. THE CONTACT STATED THAT WHILE DRIVING 10 MPH, ANOTHER VEHICLE CRASHED INTO THE PASSENGER SIDE OF THE CONTACT. UPON IMPACT, THE AIR BAGS FAILED TO DEPLOY. THE DRIVER SUSTAINED A CONTUSION ON THE SHOULDER. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE AIR BAGS WERE FAULTY. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS DESTROYED. THE FAILURE AND CURRENT MILEAGE WAS 127,000.

Mileage: 127,000

THE FOLLOWING REQUEST WAS RECEIVED FROM THE NTSB WEB SITE: MESSAGE: VAN ACCIDENT INCIDENT - 2000 DODGE VAN 2500 ON TUESDAY, MAY 22, 2012 AROUND 4PM, I WAS ON MY WAY TO MARYVILLE TO PICK UP A TV. TRAVELING SOUTH ON EBENEZER ROAD, I ENGAGED THE CRUISE CONTROL SETTING IT AT 45 MPH. APPROACHING NORTH SHORE IN THE RIGHT LANE, I SAW 4-6 CARS WAITING AT THE LIGHT. I TAP THE BRAKE TO DISENGAGE THE CRUISE CONTROL AND IMMEDIATELY FELT THE VAN ACCELERATION. I TURNED INTO THE LEFT LANE TO MI

THE FOLLOWING REQUEST WAS RECEIVED FROM THE NTSB WEB SITE: MESSAGE: VAN ACCIDENT INCIDENT - 2000 DODGE VAN 2500 ON TUESDAY, MAY 22, 2012 AROUND 4PM, I WAS ON MY WAY TO MARYVILLE TO PICK UP A TV. TRAVELING SOUTH ON EBENEZER ROAD, I ENGAGED THE CRUISE CONTROL SETTING IT AT 45 MPH. APPROACHING NORTH SHORE IN THE RIGHT LANE, I SAW 4-6 CARS WAITING AT THE LIGHT. I TAP THE BRAKE TO DISENGAGE THE CRUISE CONTROL AND IMMEDIATELY FELT THE VAN ACCELERATION. I TURNED INTO THE LEFT LANE TO MI

TL* THE CONTACT OWNS A 2000 DODGE CARAVAN. THE CONTACT STATED THAT THE DRIVER SIDE VISOR WAS LOOSE AND HUNG OVER THE STEERING WHEEL, BLOCKING THE CONTACT'S VISION OF THE ROADWAY AND CAUSING DIFFICULTY IN STEERING ATTEMPTS. THE CONTACT CRASHED INTO A CURVE BECAUSE OF THE FAILURE. AS A RESULT, THE FRONT PASSENGER SIDE TIRE EXPLODED AND DAMAGE WAS CAUSED TO THE VEHICLE. THE VEHICLE WAS NOT INSPECTED OR REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 100,000 AND THE CURRENT MILEAGE WAS

Mileage: 100,000

SERPENTINE BELT SLIPS OFF IN THE RAIN CAUSING A LOSS IN POWER STEERING, AC (FOR WINDOW DEFOGGING), POWER (NO ALTERNATOR WHEN HEADLIGHTS ARE ON DURING RAIN). WHEN IT SLIPPED OFF, THE ABILITY TO CORRECT FOR LOSS OF TRACTION DUE TO WATER WAS REDUCED DUE TO LACK OF POWER STEERING AND THE WINDSHIELD FOGGED UP QUICKLY DUE TO THE LOSS OF THE AC COMPRESSOR. SLID OF THE INTERSTATE AND SLID DOWN THE MEDIAN. MULTIPLE OTHER INSTANCES OF BELT SLIPPING OFF (4 TIMES IN PAST 3 DAYS), THOUGH AT LOWER RATES

Mileage: 140,000

SERPENTINE BELT SLIPS OFF IN THE RAIN CAUSING A LOSS IN POWER STEERING, AC (FOR WINDOW DEFOGGING), POWER (NO ALTERNATOR WHEN HEADLIGHTS ARE ON DURING RAIN). WHEN IT SLIPPED OFF, THE ABILITY TO CORRECT FOR LOSS OF TRACTION DUE TO WATER WAS REDUCED DUE TO LACK OF POWER STEERING AND THE WINDSHIELD FOGGED UP QUICKLY DUE TO THE LOSS OF THE AC COMPRESSOR. SLID OF THE INTERSTATE AND SLID DOWN THE MEDIAN. MULTIPLE OTHER INSTANCES OF BELT SLIPPING OFF (4 TIMES IN PAST 3 DAYS), THOUGH AT LOWER RATES

Mileage: 140,000

SERPENTINE BELT SLIPS OFF IN THE RAIN CAUSING A LOSS IN POWER STEERING, AC (FOR WINDOW DEFOGGING), POWER (NO ALTERNATOR WHEN HEADLIGHTS ARE ON DURING RAIN). WHEN IT SLIPPED OFF, THE ABILITY TO CORRECT FOR LOSS OF TRACTION DUE TO WATER WAS REDUCED DUE TO LACK OF POWER STEERING AND THE WINDSHIELD FOGGED UP QUICKLY DUE TO THE LOSS OF THE AC COMPRESSOR. SLID OF THE INTERSTATE AND SLID DOWN THE MEDIAN. MULTIPLE OTHER INSTANCES OF BELT SLIPPING OFF (4 TIMES IN PAST 3 DAYS), THOUGH AT LOWER RATES

Mileage: 140,000

TL* THE CONTACT OWNS A 2000 DODGE CARAVAN. THE CONTACT WAS TRAVELING 60 MPH WHEN THE CONTACT CRASHED INTO A DEER. THE AIR BAGS DID NOT DEPLOY AND THE VEHICLE WAS DESTROYED. THE VEHICLE WAS REPAIRED OR INSPECTED FOR THE AIR BAG FAILURE. THE FAILURE MILEAGE WAS 196,000.

Mileage: 196,000

TL*THE CONTACT OWNS A 2000 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE FRONT PASSENGER SIDE SPINDLE BROKE ON THE TIE ROD CAUSING THE WHEEL TO BUCKLE UNDERNEATH, AS A RESULT SHE LOST CONTROL AND THE VEHICLE ROLLED OVER. A POLICE REPORT WAS FILED. FOUR PEOPLE IN THE VEHICLE SUSTAINED INJURIES. THE CONTACTED STATED THAT THEY ALL SUFFERED INJURIES ON THEIR KNEES, BACK AND NECK. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO DECLARED THE VEHICLE DESTROYED. THE MANUFACTURER WAS NOT CONTACTED. THE

Mileage: 150,000

TL*THE CONTACT OWNS A 2003 DODGE GRAND CARAVAN. WHILE THE CONTACT ATTEMPTED TO BRAKE, THE VEHICLE SUDDENLY ACCELERATED. THE FAILURE OCCURRED TWICE. ONE TIME, THE VEHICLE CRASHED INTO A METAL POLE AND THE SECOND TIME, IT ACCELERATED INTO BUSHES AND STOPPED WHEN IT HIT A FENSE. THE CONTACT SUFFERED INJURIES TO HER ARM. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP WHERE THE CONTACT WAS INFORMED THAT THE ABS WAS THE CAUSE OF THE FAILURES AND THE LEFT REAR SPEED SENSOR WAS REPLACED. THE FAILURE MILEA

Mileage: 83,500

MY 4 CHILDREN WERE IN MY VAN WHILE IT WAS PARKED AND MY 5 YR OLD GOT INTO DRIVERS SEAT AND PULLED GEAR SHIFT IN REVERSE AND VAN ROLLED DOWN DRIVEWAY, ACROSS ROAD, AND OVER AN EMBANKMENT AND IT TOTALED THE VEHICLE. THIS SHOULD NOT HAVE HAPPENED, THE GEAR SHIFT SHOULD NOT HAVE MOVED WHILE IT WAS IN PARK WITHOUT THE BRAKES BEING APPLIED TO GET IT OUT OF GEAR. MY DAUGHTER HAD TO HAVE STITCHES AS A RESULT OF THIS ACCIDENT. THEY COULD HAVE BEEN KILLED. *TR

Mileage: 71,000

TL*THE CONTACT OWNS A 2000 DODGE CARAVAN. WHILE DRIVING APPROXIMATELY 10 MPH, THE AIR BAGS SUDDENLY DEPLOYED. THE FAILURE CAUSED NON-SEVERE BURNS TO THE DRIVER'S HANDS. THE VEHICLE WAS TOWED TO A GAS STATION AND THE MECHANIC INFORMED THE DRIVER OF NHTSA CAMPAIGN ID NUMBER 04V480000 (AIR BAGS) AND REFERRED HIM TO NHTSA. THE MANUFACTURER AND DEALER HAVE NOT BEEN NOTIFIED. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 121,700. UPDATED 02/05/09. *LJ UPDATED 02/10/09. *JB

Mileage: 121,700