2005 CHEVROLET UPLANDER

PARKING BRAKE

CERTAIN SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, 'PASSENGER CAR BRAKE SYSTEMS.' TO MEET THE STANDARD, THE VEHICLE MUST NOT MOVE FOR FIVE MINUTES WHEN STOPPED ON A STEEP HILL WITH THE PARKING BRAKE APPLIED AND THE VEHICLE IN NEUTRAL

SUSPENSION:REAR

THE BRAUN CORPORATION HAS NOTIFIED NHTSA ABOUT A DEFECT IN CERTAIN MODEL YEAR 2005-2008 GENERAL MOTORS MOBILITY CONVERSION, HANDICAPPED ACCESSIBLE LOW FLOOR MINIVANS. DURING CONVERSION, THE DRIVER OR PASSENGER SIDE TRAILING ARM MODIFICATION MAY NOT HAVE BEEN ADEQUATELY WELDED.

SEATS:MID/REAR ASSEMBLY

ON CERTAIN MINIVANS, THE OUTBOARD RELEASE HANDLE ON THE IMPACT-SIDE SECOND-ROW BUCKET SEAT MAY BE ACTUATED AND THE REAR LATCHES MAY UNLATCH EARLY IN A SIDE IMPACT CRASH. THIS WAS DISCOVERED IN A SIDE IMPACT TEST RUN BY GM, UNDER CONDITIONS SIMILAR TO NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) SIDE

STEERING

DORMAN IS RECALLING 979 STEERING KNUCKLES, DORMAN P/NOS. 697-902 AND 697-903, SOLD UNDER DORMAN'S "OE SOLUTIONS<SUP>TM</SUP>" BRAND NAME, AND NAPA P/NOS. 7-8502 AND 7-8503 WHICH WERE SOLD FOR REPLACEMENT USE ON THE VARIOUS VEHICLES LISTED ABOVE. A POTENTIAL MATERIAL OR DESIGN DEFECT COULD RESULT IN

THE CHASSIS HAS A SERIOUS RUST ISSUE AS I'VE NEVER SEEN BEFORE. THE RUST ISSUE IS ONE THAT YOU WOULD NOT EVEN SEE ON A 60 YEAR OLD CAR. IT CAUSED THE REAR WHEEL AND ALL OF ITS COMPONENTS TO BREAK FREE. I DO HAVE PICTURES (IT'S DARK OUT RIGHT AT THE MOMENT BUT I CAN BY MORNING) I HAVE BEEN TRYING TO FIND A SOLUTION FOR THIS FOR QUIET A WHILE NOW.

Mileage: 5

THE CHASSIS HAS A SERIOUS RUST ISSUE AS I'VE NEVER SEEN BEFORE. THE RUST ISSUE IS ONE THAT YOU WOULD NOT EVEN SEE ON A 60 YEAR OLD CAR. IT CAUSED THE REAR WHEEL AND ALL OF ITS COMPONENTS TO BREAK FREE. I DO HAVE PICTURES (IT'S DARK OUT RIGHT AT THE MOMENT BUT I CAN BY MORNING) I HAVE BEEN TRYING TO FIND A SOLUTION FOR THIS FOR QUIET A WHILE NOW.

Mileage: 5

THE CHASSIS HAS A SERIOUS RUST ISSUE AS I'VE NEVER SEEN BEFORE. THE RUST ISSUE IS ONE THAT YOU WOULD NOT EVEN SEE ON A 60 YEAR OLD CAR. IT CAUSED THE REAR WHEEL AND ALL OF ITS COMPONENTS TO BREAK FREE. I DO HAVE PICTURES (IT'S DARK OUT RIGHT AT THE MOMENT BUT I CAN BY MORNING) I HAVE BEEN TRYING TO FIND A SOLUTION FOR THIS FOR QUIET A WHILE NOW.

Mileage: 5

MY DAUGHTER WAS DRIVING MY CAR WITH THE HEATED SEATS ON. SHE FELT IT GET EXTREMELY HOT. SHE TURNED OFF SEAT WARMERS. WHEN SHE GOT OUT OF CAR, THE SEAT HAD MELT/BURN MARKS AND HER LEGGINGS AND SKIN HAD BURN/RED MARKS. I HAD A MECHANIC LOOK INTO THIS AND HE SAID DO NOT USE SEAT WARMERS-IT WILL CAUSE A FIRE. NEW SEAT IS AT LEAST $500 WITHOUT LABOR. MAKES ME QUESTION ENTIRE ELECTRICAL SYSTEM. IN ADDITION, YOU HAVE CONNECTED SO MANY THINGS TOGETHER, THAT REPLACING ONE THING MEANS REPLACING A WHOLE

Mileage: 167,000

MY DAUGHTER WAS DRIVING MY CAR WITH THE HEATED SEATS ON. SHE FELT IT GET EXTREMELY HOT. SHE TURNED OFF SEAT WARMERS. WHEN SHE GOT OUT OF CAR, THE SEAT HAD MELT/BURN MARKS AND HER LEGGINGS AND SKIN HAD BURN/RED MARKS. I HAD A MECHANIC LOOK INTO THIS AND HE SAID DO NOT USE SEAT WARMERS-IT WILL CAUSE A FIRE. NEW SEAT IS AT LEAST $500 WITHOUT LABOR. MAKES ME QUESTION ENTIRE ELECTRICAL SYSTEM. IN ADDITION, YOU HAVE CONNECTED SO MANY THINGS TOGETHER, THAT REPLACING ONE THING MEANS REPLACING A WHOLE

Mileage: 167,000

TL* THE CONTACT OWNED A 2005 CHEVROLET UPLANDER. WHILE DRIVING 65 MPH, THE VEHICLE HYDROPLANED, CRASHED INTO A GUARDRAIL, AND FLIPPED OVER SEVERAL TIMES. THE AIR BAGS FAILED TO DEPLOY. THERE WERE NO INJURIES AND A POLICE REPORT WAS FILED. THE VEHICLE WAS DESTROYED AND TOWED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 70,000.

Mileage: 70,000

A DRIVER PARKED HER VEHICLE SUCH THAT THE REAR OF HER VEHICLE WAS FACING DOWNHILL. SHE THOUGHT SHE PLACED THE VEHICLE IN PARK AND TURNED THE IGNITION OFF. SHE LEFT THE KEY IN THE IGNITION AND BEGAN TO CLEAN THE INTERIOR OF THE VEHICLE FROM THE FRONT PASSENGER SIDE. HER TWO YEAR OLD SON WAS STANDING ON THE DRIVERS SEAT. WHILE SHE WAS CLEANING THE INTERIOR, SHE HEARD A CLICK AND THE VEHICLE BEGAN TO ROLL BACKWARDS. SHE WAS UNABLE TO STOP THE VEHICLE FROM ROLLING BACKWARDS. SHE WAS INJURED

Mileage: 90,000

A DRIVER PARKED HER VEHICLE SUCH THAT THE REAR OF HER VEHICLE WAS FACING DOWNHILL. SHE THOUGHT SHE PLACED THE VEHICLE IN PARK AND TURNED THE IGNITION OFF. SHE LEFT THE KEY IN THE IGNITION AND BEGAN TO CLEAN THE INTERIOR OF THE VEHICLE FROM THE FRONT PASSENGER SIDE. HER TWO YEAR OLD SON WAS STANDING ON THE DRIVERS SEAT. WHILE SHE WAS CLEANING THE INTERIOR, SHE HEARD A CLICK AND THE VEHICLE BEGAN TO ROLL BACKWARDS. SHE WAS UNABLE TO STOP THE VEHICLE FROM ROLLING BACKWARDS. SHE WAS INJURED

Mileage: 90,000

PULLED DOWN ON REAR DOOR STRAP, AND ONE ATTACH BRACKET BROKE WITH RIVET STILL ATTACHED TO STRAP. THE DOWNWARD MOTION BROUGHT MY HAND ACROSS THE RIVET, RESULTING IN A HAND CUT. ONE END OF THE ATTACH RIVET IS SMOOTH AND THE OTHER END IS KNIFE SHARP. THE REPLACEMENT STRAP PURCHASED FROM GM DEALERSHIP IS SAME DESIGN. IF BOTH ENDS OF THE RIVET WERE SMOOTH, NO INJURY WOULD HAVE HAPPENED. *TR

Mileage: 96,000

PASSENGER SIDE HEADLAMP BULB HOLDER LOOSENED AND FELL TO REST ON HEADLIGHT HOUSING MELTING THE PLASTIC AND STARTED A FIRE,MELTED WIRING HARNESS COMPLETE HEADLIGHT ASSEMBLY AND HEADLIGHT MOUNTING ASSEMBLY, FIRE WAS PUT OUT RIGHT AWAY COULD HAVE BURN THE WHOLE CAR FLAMES WHERE SHOOTING OUT OF ENGINE COMPARTMENT. *TR

Mileage: 20,308

PASSENGER SIDE HEADLAMP BULB HOLDER LOOSENED AND FELL TO REST ON HEADLIGHT HOUSING MELTING THE PLASTIC AND STARTED A FIRE,MELTED WIRING HARNESS COMPLETE HEADLIGHT ASSEMBLY AND HEADLIGHT MOUNTING ASSEMBLY, FIRE WAS PUT OUT RIGHT AWAY COULD HAVE BURN THE WHOLE CAR FLAMES WHERE SHOOTING OUT OF ENGINE COMPARTMENT. *TR

Mileage: 20,308

ON DECEMBER 15, 2011, A 2005 CHEVROLET UPLANDER WAS DRIVEN ON A SIDE STREET AT APPROXIMATELY 25 MPH. WITHOUT WARNING, THE WHEEL JERKED OUT OF THE DRIVER'S HAND AND THE VEHICLE STRUCK A PARKED VEHICLE AND CAME TO A STOP. NO ONE WAS INJURED. A FORENSIC ENGINEERING INVESTIGATION REVEALED THAT THE FAILURE OF THE RIGHT STEERING KNUCKLE WAS THE SOLE CAUSE OF THIS INCIDENT. THE PART NUMBER ON THE FRONT OF THE BOTTOM PORTION OF THE STEERING KNUCKLE IS "INTERMEDIATE 0472 98 U/W R". THE CASTING NUMBE

Mileage: 99,261

ON DECEMBER 15, 2011, A 2005 CHEVROLET UPLANDER WAS DRIVEN ON A SIDE STREET AT APPROXIMATELY 25 MPH. WITHOUT WARNING, THE WHEEL JERKED OUT OF THE DRIVER'S HAND AND THE VEHICLE STRUCK A PARKED VEHICLE AND CAME TO A STOP. NO ONE WAS INJURED. A FORENSIC ENGINEERING INVESTIGATION REVEALED THAT THE FAILURE OF THE RIGHT STEERING KNUCKLE WAS THE SOLE CAUSE OF THIS INCIDENT. THE PART NUMBER ON THE FRONT OF THE BOTTOM PORTION OF THE STEERING KNUCKLE IS "INTERMEDIATE 0472 98 U/W R". THE CASTING NUMBE

Mileage: 99,261

TL *THE CONTACT OWNS A 2005 CHEVROLET UPLANDER. THE CONTACT STATED THAT WHILE TRYING TO CLOSE THE SLIDING DOOR OF THE VEHICLE HIS FINGER WAS AMPUTATED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 51, 500.

Mileage: 51,500

MY WIFE REARENDED ANOTHER VEHICLE AND THE AIR BAGS DID NOT DEPLOY. THERE'S AN ESTIMATE DAMAGE OF 768 DOLLARS IN JUST PARTS ALONE. *TR

Mileage: 76,000

TL*THE CONTACT OWNS A 2005 CHEVROLET UPLANDER LS. WHILE DRIVING IN REVERSE 2 MPH SHE HEARD A LOUD POP. SHE FELT SOMETHING ON HER LEFT FOOT AND NOTICED BLOOD AND HER RIGHT KNEE WAS ALSO BLEEDING. SHE STATED THAT THE VEHICLE WAS ACCELERATING AND MOVING BACKWARDS. THE VEHICLE STALLED IN THE MIDDLE OF THE STREET FORCING HER TO USE ALL OF HER BODY WEIGHT IN ORDER TO STOP THE VEHICLE. SHE HAD TO USE ALL OF HER BODY WEIGHT IN ORDER TO SHIFT GEARS AND STOP THE VEHICLE. AFTER THE VEHICLE STOPPED, SHE

Mileage: 68,000

THE CAR INTERMITTENTLY TRIES TO START THE CRANK KEEPS TURNING BUT DOES NOT START. AS WELL AS I WAS TRAVELING ON FREEWAY WITH A BIG RIG ON THE SIDE OF ME AND THE CAR STALLED AND STEERING LOCKED. THANK GOD I MANAGED TO GLIDE OVER TO THE EXIT LANE. I WAS TERRIFIED AS WAS MY PASSENGER. WHEN I LOOKED AT THE GAUGES I NOTICED I WAS OUT OF GAS, BUT I HAD JUST PUT IN $20 . CHEVY SENT OUT TOW TRUCK TO GIVE ME GAS, BUT CAR STILL WOULD NOT START. FINALLY HOURS LATER CAR WAS TAKEN TO CHEVY. WHEN UPLANDER WA

Mileage: 11,000

THE CAR INTERMITTENTLY TRIES TO START THE CRANK KEEPS TURNING BUT DOES NOT START. AS WELL AS I WAS TRAVELING ON FREEWAY WITH A BIG RIG ON THE SIDE OF ME AND THE CAR STALLED AND STEERING LOCKED. THANK GOD I MANAGED TO GLIDE OVER TO THE EXIT LANE. I WAS TERRIFIED AS WAS MY PASSENGER. WHEN I LOOKED AT THE GAUGES I NOTICED I WAS OUT OF GAS, BUT I HAD JUST PUT IN $20 . CHEVY SENT OUT TOW TRUCK TO GIVE ME GAS, BUT CAR STILL WOULD NOT START. FINALLY HOURS LATER CAR WAS TAKEN TO CHEVY. WHEN UPLANDER WA

Mileage: 11,000

THE CAR INTERMITTENTLY TRIES TO START THE CRANK KEEPS TURNING BUT DOES NOT START. AS WELL AS I WAS TRAVELING ON FREEWAY WITH A BIG RIG ON THE SIDE OF ME AND THE CAR STALLED AND STEERING LOCKED. THANK GOD I MANAGED TO GLIDE OVER TO THE EXIT LANE. I WAS TERRIFIED AS WAS MY PASSENGER. WHEN I LOOKED AT THE GAUGES I NOTICED I WAS OUT OF GAS, BUT I HAD JUST PUT IN $20 . CHEVY SENT OUT TOW TRUCK TO GIVE ME GAS, BUT CAR STILL WOULD NOT START. FINALLY HOURS LATER CAR WAS TAKEN TO CHEVY. WHEN UPLANDER WA

Mileage: 11,000

THE CAR INTERMITTENTLY TRIES TO START THE CRANK KEEPS TURNING BUT DOES NOT START. AS WELL AS I WAS TRAVELING ON FREEWAY WITH A BIG RIG ON THE SIDE OF ME AND THE CAR STALLED AND STEERING LOCKED. THANK GOD I MANAGED TO GLIDE OVER TO THE EXIT LANE. I WAS TERRIFIED AS WAS MY PASSENGER. WHEN I LOOKED AT THE GAUGES I NOTICED I WAS OUT OF GAS, BUT I HAD JUST PUT IN $20 . CHEVY SENT OUT TOW TRUCK TO GIVE ME GAS, BUT CAR STILL WOULD NOT START. FINALLY HOURS LATER CAR WAS TAKEN TO CHEVY. WHEN UPLANDER WA

Mileage: 11,000