2003 CHEVROLET TAHOE

EXTERIOR LIGHTING

CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE D

SEAT BELTS:REAR/OTHER

ON CERTAIN CREW CAB PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE 2ND ROW CENTER OCCUPANT SEAT BELT ROUTING MAY MAKE IT DIFFICULT TO POSITION THE LAP PORTION OF THE SAFETY BELT LOW AROUND THE HIPS OF OCCUPANTS, ESPECIALLY SMALLER OCCUPANTS, SEATED IN THIS POSITION. APPROPRIATE USE OF A CHILD SEAT

FUEL SYSTEM, GASOLINE

CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CE

WHEELS:HUB

CERTAIN FEDERAL-MOGUL REPLACEMENT WHEEL HUB ASSEMBLIES WITH THE BRAND NAMES: NATIONAL, CARQUEST P/NOS. 515020, 515021, 515025, 515053, 515054, 515059, AND 515060, SHIPPED BETWEEN JANUARY 23, 2006, AND DECEMBER 20, 2007, SOLD FOR LIGHT DUTY AND MEDIUM DUTY TRUCKS. THE INBOARD RETENTION NUT USED TO M

STRUCTURE

CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EX

STRUCTURE:BODY:DOOR:HINGE AND ATTACHMENTS

CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 214, "SIDE IMPACT PROTECTION." THESE VEHICLES ARE BUILT WITH FOUR WELDS ON THE REAR DOOR UPPER HINGE. ON SOME OF THESE VEHICLES, ONE OR TWO OF THE WELDS MAY NOT BE TO SPECIFICATION.

SERVICE BRAKES, HYDRAULIC

CERTAIN SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND PASSENGER VANS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, ?PASSENGER CAR BRAKE SYSTEMS.? SOME OF THESE VEHICLES WERE PRODUCED WITH AN OUT-OF-SPECIFICATION BRAKE HYDRO-BOOST HOUSING RELIEF VALVE BORE.

WHILE DRIVING THE TAHOE CLOSE TO HOME I STARTED TO SMELL OF BURNING AND I COULD SEE SMOKE COMING UP FROM THE DASH. I PULLED OVER AND BY THEN THE WHOLE CAR WAS FILLED WITH SMOKE AND I COULD SEE FLAMES COMING FROM UNDER THE DASH ON THE PASSENGER SIDE. I TRIED TO PUT OUT THE FLAMES (NOT RECOMMENDED) BUT THE FIRE JUST SPREAD UPWARDS INTO THE DASH AND WAS OBVIOUSLY OUT OF CONTROL. I LEFT THE VEHICLE AND CALLED 911 AND WITHIN MINUTES THE WHOLE FRONT OF THE CAR WAS ENGULFED IN FLAMES. THE POLICE AND FI

Mileage: 63,000

TAKATA RECALL, TODAY, MAY 31, 2019, I DROVE MY TRUCK TO A MEETING AT 1:30 IN THE AFTERNOON AND PARKED MY VEHICLE IN THE PARKING LOT (IT WAS STATIONARY IN A CITY PARKING LOT). WHEN I RETURNED TO MY CAR AFTER THE MEETING AT 3:30 IN THE AFTERNOON I OPEN MY CAR AND THE INTERIOR WAS ENGULFED IN SMOKE. A COMPONENT OF THE POWER SEAT ON THE DRIVERS SIDE STARTED THE FIRE. IT WAS FORTUNATE NO ONE WAS IN THE TRUCK AT THE TIME AND THE WINDOWS WERE CLOSED. AFTER THE FIRE IGNITED AND USED UP ALL THE O

Mileage: 276

TAKATA RECALL, TODAY, MAY 31, 2019, I DROVE MY TRUCK TO A MEETING AT 1:30 IN THE AFTERNOON AND PARKED MY VEHICLE IN THE PARKING LOT (IT WAS STATIONARY IN A CITY PARKING LOT). WHEN I RETURNED TO MY CAR AFTER THE MEETING AT 3:30 IN THE AFTERNOON I OPEN MY CAR AND THE INTERIOR WAS ENGULFED IN SMOKE. A COMPONENT OF THE POWER SEAT ON THE DRIVERS SIDE STARTED THE FIRE. IT WAS FORTUNATE NO ONE WAS IN THE TRUCK AT THE TIME AND THE WINDOWS WERE CLOSED. AFTER THE FIRE IGNITED AND USED UP ALL THE O

Mileage: 276

EXITING FROM THE EXPRESSWAY WITH TRAFFIC LIGHT ABOUT 20 YARDS AWAY, CARS WERE STOPED DUE TO RED LIGHT AND I AM COMING DOWN HILL EXITING. APPLYING THE BREAKS AND THE PADDLE GOES TO THE FLOOR, I REAR ENDED THE VEHICLE ON THE FAR RIGHT .

Mileage: 93,000

MY TAHOE CAUGHT FIRE INSIDE THE DRIVER SIDE DASH. IT WAS PARKED, NO ONE HAD DRIVEN IT THAT DAY. I PUT IN A CLAIM WITH GM (CLAIM #SR 8-2955875514) AND IT WAS DENIED AS THEY SAID THERE ARE NO RECALLS FOR MY TAHOE. THIS FIRE STARTED OUT OF NO WHERE. THANK GOODNESS OUR NEIGHBOR CAME BANGING AT THE DOOR TO LET US KNOW THAT OUR TAHOE WAS ON FIRE. WE WEREN'T HOME AT THE TIME BUT MY SON WAS, WE ARRIVED TO FIND HIM WITH THE WATER HOSE EXTINGUISHING THE FLAMES THAT WERE COMING FROM INSIDE THE VEHICLE. I S

Mileage: 246,000

MY TAHOE CAUGHT FIRE INSIDE THE DRIVER SIDE DASH. IT WAS PARKED, NO ONE HAD DRIVEN IT THAT DAY. I PUT IN A CLAIM WITH GM (CLAIM #SR 8-2955875514) AND IT WAS DENIED AS THEY SAID THERE ARE NO RECALLS FOR MY TAHOE. THIS FIRE STARTED OUT OF NO WHERE. THANK GOODNESS OUR NEIGHBOR CAME BANGING AT THE DOOR TO LET US KNOW THAT OUR TAHOE WAS ON FIRE. WE WEREN'T HOME AT THE TIME BUT MY SON WAS, WE ARRIVED TO FIND HIM WITH THE WATER HOSE EXTINGUISHING THE FLAMES THAT WERE COMING FROM INSIDE THE VEHICLE. I S

Mileage: 246,000

WHILE DRIVING THE BRAKES TOTALLY FAILED. PEDAL WENT TO THE FLOOR WITH NO BRAKES AT ALL. VEHICLE HAD TO RUN OFF THE ROAD AND STOP USING THE EMERGENCY BRAKE. AS SOON AS THE BRAKE PEDAL WAS PUSHED IT WENT TO THE FLOOR AND THEN WARNINGS LIGHT TO SERVICE ABS STARTED FLASHING AND BEEPING. THERE WAS NO WARNING PRIOR TO THE FAILURE OF THE BRAKE SYSTEM. AFTER THE VEHICLE WAS TOWED WE FOUND THAT THERE WAS NO BRAKE FLUID AND A LARGE RUPTURE WAS FOUND IN THE BRAKE LINE ON THE DRIVERS SIDE TOWARDS THE F

Mileage: 202,000

TL* THE CONTACT OWNED A 2003 CHEVROLET TAHOE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 45 MPH, THE CONTACT LOST CONTROL OF THE VEHICLE AND CRASHED INTO A GUARD RAIL. THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS FILED. THE FRONT SEAT PASSENGER SUSTAINED 12 BROKEN RIBS AND 2 COLLAPSED LUNGS THAT REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS TOWED TO AN INDEPENDENT TOWING FACILITY. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UN

TL* THE CONTACT OWNS A 2003 CHEVROLET TAHOE. WHILE DRIVING 60 MPH IN RAINY WEATHER, THE BRAKES WERE ABRUPTLY APPLIED TO AVOID A COLLISION. THE BRAKES DID NOT RESPOND AND THE CONTACT SWERVED TO AVOID CRASHING INTO THE REAR OF ANOTHER VEHICLE. THE CONTACT CRASHED INTO A DITCH. THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS NOT FILED. THE CONTACT WAS NOT INJURED. THE VEHICLE WAS ABLE TO BE DRIVEN TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT MA

Mileage: 68,000

AS I WAS BACKING OUT OF MY DRIVEWAY I HIT THE BRAKES AND THE TRUCK DIDN'T STOP CAUSING ME TO HIT MY NEIGHBORS TREE. .. THE BRAKE SYSTEM FAILED WITH NO WARNING OR SIGNAL LIGHT OR A SOUND. AS I LOOKED UNDER THE TRUCK THERE WAS BRAKE FLUID ALL OVER THE STREET. I CALLED A BUDDY MECHANIC OF MINE AND STATED MY BRAKE LINES ARE RUSTED OUT. *TR

Mileage: 128,000

TL* THE CONTACT OWNS A 2003 CHEVROLET TAHOE. THE CONTACT STATED THAT WHILE TRAVELING APPROXIMATELY 35 MPH, THE FRONT DRIVER'S SIDE SEAT WARMER WAS ACTIVATED AND AN UNEXPECTED HIGH AMOUNT OF HEAT PENETRATED THROUGH THE BACK OF THE SEAT. THE CONTACT SUSTAINED A HEAT RASH TO HER BACK. THERE WAS ALSO A SMALL BURN MARK ON THE SEAT BACK. THE VEHICLE HAD NOT BEEN DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 174,000.

Mileage: 174,000

MY ACCELERATION PEDAL ENGAGED AND RAN THRU CENTER BLOCK FENCE. NO AIRBAG ON EITHER SIDE....THANKS A LOT..... DRIVER. *TR

Mileage: 90,000

MY ACCELERATION PEDAL ENGAGED AND RAN THRU CENTER BLOCK FENCE. NO AIRBAG ON EITHER SIDE....THANKS A LOT..... DRIVER. *TR

Mileage: 90,000

BRAKES LINE BURST DUE TO EXCESS AMOUNT OF RUST UNDER VEHICLE. CALLED DEALER WHERE IT HAS BEEN SERVICED FOR LAST 8 YEARS. SERVICE MANAGER SAID HE WAS WELL AWARE OF PROBLEM AND THAT REPLACEMENT LINES...NOT REVISED ONE BUT OEM ONES WHICH WILL DO THE SAME AGAIN WE'RE BACK ORDERED DUE TO DEMAND. HE SAID A LOT OF CLIENTS WERE HAVING THEIR VEHICLES RESOLVED AND THAT REPLACEMENT PART COULD POSSIBLY BE MONTHS TO OBTAIN.. IDIOTS AND WHEN IS CHEVY GOING TO DO SOMETHING BEFORE MORE PEOPLE GET HURT OR WORSE

Mileage: 87,000

TL* THE CONTACT OWNS A 2003 CHEVROLET TAHOE. THE CONTACT STATED THAT SMOKE CAME FROM UNDER THE HOOD. THE CONTACT TOOK THE VEHICLE TO THE DEALER WHERE IT WAS DETERMINED THAT THE BLOWER RELAY RESISTER MODULE FAILED. THIS FAILURE CAUSED THE AIR CONDITIONER TO FAIL AND IT SMELLED LIKE PLASTIC WAS BURNING. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 135,000. *TR

Mileage: 135,000

MY WIFE AND 3 SONS AND 2 OTHER KIDS WERE ON THEIR WAY TO A BASEBALL TOURNAMENT. SHE WAS STOPPED WHILE A DRIVER IN FRONT OF HER WAS MAKING A U TURN. SHE WAS HIT BY ANOTHER DRIVER IN THE REAR MOSTLY ON THE DRIVERS SIDE CORNER OF OUR TAHOE. THAT CAR WENT UNDER OUR TAHOE AND KNOCKED OUR TRUCK SIDEWAYS. THE OTHER VEHICLE THAT HIT HER WAS TRAVELING AT APPROX. 50MPH. MY 11 YEAR OLD SON WAS SEAT BELTED IN THE THIRD ROW SEAT ON THE DRIVERS SIDE WHERE THE IMPACT WAS LOCATED. UPON IMPACT HIS SEAT BELT CAME

Mileage: 137,000

TL* THE CONTACT OWNS A 2003 CHEVROLET TAHOE. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, THE DRIVER ATTEMPTED TO AVOID CRASHING INTO A DEER AND LOST CONTROL OF THE VEHICLE. AS A RESULT, THE VEHICLE WAS FLIPPED SEVERAL TIMES. THE AIR BAGS FAILED TO DEPLOY AND THE DRIVER WAS KILLED. THE CONTACT DID NOT CONFIRM IF THE DRIVER WAS SECURED BY THE SEAT VEHICLE SAFETY BELT. THE VEHICLE WAS DESTROYED AND HAD NOT BEEN INSPECTED FOR THE AIR BAG FAILURE. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT

Mileage: 182,000

RETURNED TO A FRIENDS FROM A TRIP TO ACCESS MY VEHICLE AND HEAD FOR HOME. BRAKES PUSHED TO THE FLOOR AND WHEN I TRIED TO MOVE A LITTLE, CAR WOULDN'T STOP WITH EITHER THE BRAKE OR EMERGENCY BRAKE AND PROCEEDED TO ROLL FORWARD INTO A STEEP EMBANKMENT IN FRONT OF MY FRIEND'S HOME. LUCKILY I WAS NOT INJURED BUT NEEDED ALL THE BRAKES REPAIRED AND DRIVERS SIDE DOOR REPLACED. I AM IN THE PROCESS OF WAITING TO HEAR FROM MY CLAIMS ADJUSTER. *TR

Mileage: 133,000

RETURNED TO A FRIENDS FROM A TRIP TO ACCESS MY VEHICLE AND HEAD FOR HOME. BRAKES PUSHED TO THE FLOOR AND WHEN I TRIED TO MOVE A LITTLE, CAR WOULDN'T STOP WITH EITHER THE BRAKE OR EMERGENCY BRAKE AND PROCEEDED TO ROLL FORWARD INTO A STEEP EMBANKMENT IN FRONT OF MY FRIEND'S HOME. LUCKILY I WAS NOT INJURED BUT NEEDED ALL THE BRAKES REPAIRED AND DRIVERS SIDE DOOR REPLACED. I AM IN THE PROCESS OF WAITING TO HEAR FROM MY CLAIMS ADJUSTER. *TR

Mileage: 133,000

TL* THE CONTACT OWNS A 2003 CHEVROLET TAHOE. THE CONTACT STATED THAT WHILE DRIVING 30 MPH, HE APPLIED THE BRAKES AND THE VEHICLE WOULD NOT STOP. THE CONTACT CRASHED INTO ANOTHER VEHICLE DUE TO THE LACK OF BRAKES. THERE WERE NO INJURIES REPORTED DURING THE CRASH. THE VEHICLE WAS TOWED TO A LOCAL MECHANIC AND THE MECHANIC STATED THAT THE BRAKE LINES WERE CORRODED. THE MECHANIC REPLACED THE BRAKE LINES. THE FAILURE MILEAGE WAS 45,000.

Mileage: 45,000