2000 CHEVROLET CAVALIER

ELECTRICAL SYSTEM:IGNITION:SWITCH

ON CERTAIN PASSENGER VEHICLES. IF THE ENGINE FAILS TO START AND THE DRIVER HOLDS THE KEY IN THE "START" POSITION FOR AN EXTENDED PERIOD, HIGH CURRENT FLOWS THROUGH THE IGNITION SWITCH, AND SOMETIMES PRODUCES ENOUGH HEAT TO MELT INTERNAL SWITCH PARTS.

EXTERIOR LIGHTING

CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE D

INTERIOR LIGHTING

VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH THE BI-FUEL OPTION FAIL TO COMPLY WITH FMVSS NO. 101, "CONTROL LOCATION, IDENTIFICATION, AND ILLUMINATION." THE INSTRUMENT PANEL LIGHTS IN THESE VEHICLES ARE AT FULL ILLUMINATION LEVELS AND CANNOT BE ADJUSTED. THE STANDARD REQUIRES AT LEAST TW

STEERING

DORMAN PRODUCTS IS RECALLING 3,900 INTERMEDIATE STEERING SHAFTS DORMAN PART NOS. 425-151, 425-152, AND 425-153, (SOLD UNDER DORMAN'S "OE SOLUTIONS" BRAND NAME), BALKAMP #'S 7-3057, 7-3058, 7-3059 (SOLD UNDER THE "NAPA" BRAND NAME), AND PLATINUM PARTS #'S 2425151, 2425152, AND 2425153 MANUFACTURED DU

FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES

CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.

EXTERIOR LIGHTING:HEADLIGHTS

K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND A

EXTERIOR LIGHTING

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES

IGNITION GETS VERY HOT WHEN KEY IS TURNED CAN SMELL PLASTIC IGNITION OR BATT 1 CIRCUIT PROBLEM.CLEARCOAT IS PEELING.LUG NUTS COMING LOOSE

Mileage: 200,000

IGNITION GETS VERY HOT WHEN KEY IS TURNED CAN SMELL PLASTIC IGNITION OR BATT 1 CIRCUIT PROBLEM.CLEARCOAT IS PEELING.LUG NUTS COMING LOOSE

Mileage: 200,000

IGNITION GETS VERY HOT WHEN KEY IS TURNED CAN SMELL PLASTIC IGNITION OR BATT 1 CIRCUIT PROBLEM.CLEARCOAT IS PEELING.LUG NUTS COMING LOOSE

Mileage: 200,000

TL* THE CONTACT OWNS A 2000 CHEVROLET CAVALIER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 50 MPH, THE DRIVER CRASHED INTO A TREE. THE AIR BAGS FAILED TO DEPLOY. THE DRIVER WAS KILLED. A POLICE REPORT WAS FILED OF THE INCIDENT. THE VEHICLE WAS TOWED TO AN IMPOUND LOT. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS DESTROYED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 130,000. *TR

Mileage: 130,000

I WAS DRIVING DOWN THE ROAD AND A LARGE PICK UP TRUCK PULLED OUT IN FRONT OF ME AND I SMASHED INTO THE SIDE OF THE TRUCK AND NEITHER THE DRIVER OR PASSENGER AIRBAGS DEPLOYED. I WAS GOING APPROXIMATELY 45 MPH ON IMPACT. *TR

Mileage: 138,000

MY DAUGHTER WAS DRIVING THE 2000 CAVALEIR FROM CHURCH TO HER COLLEGE WHEN SHE STOPPED AT A STOP SIGN AND LOOKED LEFT AND THEN RIGHT AND PROCEEDED THROUGH THE INTERSECTION AND FAILED TO SEE A CHRYSLER MINIVAN COMING FROM HER LEFT.. SHE BRAKED AND THE MINIVAN T-BONED HER CAR ON THE LEFT SIDE AND HER CAR PROCEEDED TO TURN 90 DEGREES TO THE RIGHT FOR 20 FEET AND STOPPED. THE MOST DAMAGE OCCURED ON THE PASSENGER DOOR, TO THE FRONT TIRE WAS PUSHED IN...THE WHOLE STEERING WHEEL ASSEMBLY WAS PUSHED FO

Mileage: 102,000

TL*THE CONTACT OWNS A 2000 CHEVROLET CAVALIER. THE CONTACT EXPERIENCED ISSUES STARTING THE VEHICLE. THE DEALER COULD NOT IDENTIFY THE FAILURE; HOWEVER, A MUFFLER SHOP REPAIRED THE STARTER ON THE VEHICLE. AFTER THE REPAIR, THE STARTER BEGAN TO OVERHEAT AND BURNED THE INTERIOR OF THE VEHICLE. THE CURRENT MILEAGE WAS 91,812 AND FAILURE MILEAGE WAS 91,600. UPDATED 03-30-09 *BF THE CONSUMER STATED AN UNNECESSARY RELAY SWITCH WAS ADDED TO THE STARTER WHICH CAUSED THE STARTER TO MALFUNCTION.

Mileage: 91,600

TL*THE CONTACT OWNS A 2000 CHEVROLET CAVALIER. IN MARCH OF 2005, THE CONTACT TOOK THE VEHICLE TO THE DEALER FOR ROUTINE SERVICE AND THEY STATED THAT SHE NEEDED A RELAY SWITCH AND A NEW WIRING HARNESS. THERE WERE NO FAILURES AT THAT TIME. WHILE DRIVING 45 MPH, THE CONTACT NOTICED SMOKE AND THE KEY IN THE IGNITION WAS GETTING HOT. THE DEALER STATED THAT SHE NEEDED ANOTHER NEW IGNITION SWITCH AND WIRING HARNESS AT THE COST OF $403.23. THE FAILURE MILEAGE WAS 17,000 AND CURRENT MILEAGE WAS 32,0

Mileage: 17,000

TL*THE CONTACT OWNS A 2000 CHEVROLET CAVALIER. IN MARCH OF 2005, THE CONTACT TOOK THE VEHICLE TO THE DEALER FOR ROUTINE SERVICE AND THEY STATED THAT SHE NEEDED A RELAY SWITCH AND A NEW WIRING HARNESS. THERE WERE NO FAILURES AT THAT TIME. WHILE DRIVING 45 MPH, THE CONTACT NOTICED SMOKE AND THE KEY IN THE IGNITION WAS GETTING HOT. THE DEALER STATED THAT SHE NEEDED ANOTHER NEW IGNITION SWITCH AND WIRING HARNESS AT THE COST OF $403.23. THE FAILURE MILEAGE WAS 17,000 AND CURRENT MILEAGE WAS 32,0

Mileage: 17,000

DRIVESHAFT/POWERTRAIN FAILURE ON RIGHT SIDE DURING LOW SPEED (<15 MPH) RIGHT HAND TURN CAUSED LOSE OF CONTROL OF VEHICLE AND COLLISION WITH LIGHT POLE. DEPLOYMENT OF AIR BAGS CAUSED MINOR INJURIES TO DRIVER. VEHICLE A TOTAL LOSS. *JB

Mileage: 88,000

A FIRE IN MY 2000 CHEVROLET CAVALIER BEGAN IN THE CENTER CONSOLE APPARENTLY THE RESULT OF ELECTRICAL PROBLEMS WITH THE POWER WINDOW CONTROL WIRINGS. NO ONE WAS IN THE PARKED AND LOCKED CAR AT THE TIME OF OCCURRENCE. THE DAMAGE RESULTED IN MY INSURANCE COMPANY TOTALING THE VEHICLE. *JB

Mileage: 27,000

MY WIFE BOUGHT A 2000 CHEV. CAVALIER FROM SOUND MAZDA INRENTON A YEAR AGO IN 2004, THE CAR DID NOT PASSED EMISSION TEST, WE TOOK IT TO THE MECHANIC AND HE INFORMED US THAT THE CATALITYC CONVERTER WAS NOT WORKING, THE O2 CENSOR WAS BAD AND IT WOULD BE PRICY, WE TOOK IT TO A DEALERSHIP AND WERE GOING TO TRADE IT IN, THE MANAGER OF THE DEALERSHIP PULLED A CARFAX REPORT AND HE ASKED US IF THE DEALERSHIP HAD INFORMED US THAT IN 2002 THE CAR WAS IN A WRECK AND THE AIRBAGS WERE DEPLOYED, WE TOLD HIM NO

2 CAR VEHICLE COLLISION-SEE POLICE REPORT. ON THE ABOVE DATE AND TIME, THE BETHEL FIRE DEPARTMENT WAS DISPATCHED TO THE INTERSECTION OF RESERVOIR ST AND GRASSY PLAIN STREET FOR A MOTOR VEHICLE ACCIDENT. UPON ARRIVAL A TWO CAR MVA WAS DISCOVERED WITH A SMALL VEHICLE FIRE EXTINGUISHED BY THE BETHEL PD. BETHEL CAR ONE, PETE HOLMBERG, REQUESTED THIS FIRE MARSHAL DUE TO THE FIRE DAMAGE TO THE VEHICLE. UPON MY EXAMINATION OF THE VEHICLE, I OBSERVED THE FRONT END OF THE INVOLVED VEHICLE WITH MODE

THE WINDSHIELD EXPLODED WHILE DRIVING. CONSUMER WAS UNABLE TO MAINTAIN CONTROL OF THE VEHICLE AND CRASHED INTO A TREE. UPON IMPACT, BOTH FRONTAL AIR BAGS DID NOT DEPLOY. DRIVER AND PASSENGER SUSTAINED HEAD AND BACK INJURIES, AND WERE TRANSPORTED BY AMBULANCE TO A HOSPITAL. VEHICLE WAS TOWED AND TOTALED BY THE INSURANCE COMPANY. *AK

THE WINDSHIELD EXPLODED WHILE DRIVING. CONSUMER WAS UNABLE TO MAINTAIN CONTROL OF THE VEHICLE AND CRASHED INTO A TREE. UPON IMPACT, BOTH FRONTAL AIR BAGS DID NOT DEPLOY. DRIVER AND PASSENGER SUSTAINED HEAD AND BACK INJURIES, AND WERE TRANSPORTED BY AMBULANCE TO A HOSPITAL. VEHICLE WAS TOWED AND TOTALED BY THE INSURANCE COMPANY. *AK

A DEER RAN IN FRONT OF THE CONSUMER WHILE DRIVING, CONSUMER WAS UNABLE TO MAINTAIN CONTROL OF THE VEHICLE, AND HIT A TREE. UPON IMPACT, BOTH FRONTAL AIRBAGS DID NOT DEPLOY. NO INJURIES REPORTED. VEHICLE WAS TOWED AND TOTALED BY THE INSURANCE COMPANY.*AK

WHILE AT A STOP, A FIRE STARTED FROM THE STEERING COLUMN AND PEDAL AREA. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK

Mileage: 60,000

WHILE DRIVING 65 MPH A FIRE STARTED ON THE REAR PASSENGER SIDE OF THE VEHICLE. CONSUMER HAD THE VEHICLE TOWED TO DEALERSHIP, WHO DID NOT RESOLVE THE PROBLEM. *AK

Mileage: 118,031

AFTER PURCHASE OF MY VEHICLE - BATTERY WAS DEAD DEALER REPLACED NEW BATTERY LOST COOLANT - ENGINE WAS SMOKING THEN FOUND OUT VEHICLE WAS ON RECALL HAD TO REPLACE ROTORS AND PADS WITH LESS THAN 20,000 MILES ON VEHICLE SOMETHING NEEDS TO BE DONE TO IMPROVE THE BRAKE SYSTEM ON THE CHEVY CAVALIERS THEY DO NOT LAST. I COMMUTE TO WORK BY TRAIN AND HARDLY DRIVE SO I WAS SURPRISED WITH ALL THE PROBLEMS WITH THIS VEHICLE WITH NOT ALOT OF MILES. *NM

Mileage: 20,000

AFTER PURCHASE OF MY VEHICLE - BATTERY WAS DEAD DEALER REPLACED NEW BATTERY LOST COOLANT - ENGINE WAS SMOKING THEN FOUND OUT VEHICLE WAS ON RECALL HAD TO REPLACE ROTORS AND PADS WITH LESS THAN 20,000 MILES ON VEHICLE SOMETHING NEEDS TO BE DONE TO IMPROVE THE BRAKE SYSTEM ON THE CHEVY CAVALIERS THEY DO NOT LAST. I COMMUTE TO WORK BY TRAIN AND HARDLY DRIVE SO I WAS SURPRISED WITH ALL THE PROBLEMS WITH THIS VEHICLE WITH NOT ALOT OF MILES. *NM

Mileage: 20,000