2020 CHEVROLET BOLT EV

ELECTRICAL SYSTEM:PROPULSION SYSTEM:TRACTION BATTERY

General Motors, LLC (GM) is recalling certain 2020-2022 Chevrolet Bolt EV and 2022 Bolt EUV vehicles previously repaired under Recall 21V-650. The installation of advanced diagnostic software may have failed. As such, the high voltage battery could catch fire when charged to full or nearly full ca

ELECTRICAL SYSTEM:PROPULSION SYSTEM:TRACTION BATTERY

General Motors, LLC (GM) is recalling certain 2020-2022 Chevrolet Bolt EV and 2022 Chevrolet Bolt EUV vehicles that were previously remedied under recall number 21V-650. The advanced diagnostic software may have been incorrectly installed and fail to detect defective battery modules, possibly resul

LATCHES/LOCKS/LINKAGES:DOORS:LATCH

General Motors LLC (GM) is recalling certain 2019-2020 Chevrolet Bolt EV vehicles. The door-handle cable inside the rear doors may be too long, allowing contact with the window when it is opened, possibly damaging the cable. A damaged cable may cause the rear door to open unintentionally when the

SEAT BELTS

General Motors, LLC (GM) is recalling certain 2020 Chevrolet Bolt EV and 2021 GMC Canyon and Sierra 1500, 2500 and 3500, Yukon, Yukon XL, Cadillac Escalade and Escalade ESV and Chevrolet Blazer, Camaro, Colorado, Equinox, Silverado 1500, 2500 and 3500, Suburban and Tahoe vehicles. Incorrect bolts m

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:CALIPER

General Motors, LLC (GM) is recalling certain 2020 Chevrolet Bolt EV vehicles. These vehicles may have an improperly cast front left brake caliper that can fracture during a high-pressure braking event.

ELECTRICAL SYSTEM:PROPULSION SYSTEM:TRACTION BATTERY

General Motors, LLC (GM) is recalling certain 2020-2022 Chevrolet Bolt EV and 2022 Chevrolet Bolt EUV vehicles. The high voltage battery could catch fire when charged to full or nearly full capacity.

STRUCTURE:BODY:ROOF AND PILLARS

General Motors, LLC (GM) is recalling certain 2017-2023 Chevrolet Bolt EV vehicles. After a crash with seat belt pretensioner deployment, the pretensioner exhaust may ignite carpet fibers near the B-pillar, causing a fire.

STRUCTURE:BODY:ROOF AND PILLARS

General Motors, LLC (GM) is recalling certain 2017-2023 Chevrolet Bolt EV vehicles. This recall includes certain vehicles previously repaired incorrectly under NHTSA recall number 22V-930. After a crash with seat belt pretensioner deployment, the pretensioner exhaust may ignite carpet fibers near

Steering rack started failing: did not return to center out of slow corners. Basically I could do hands-free circles in a parking lot. Dealer confirmed the steering rack was bad and replaced it under warranty. Out of sweeping corners this can be a safety issue as it only got worse over time. No warning lights nor other indication of the problem.

While waiting to turn left at a light and driving in "L" (one pedal) mode, I started to release the break in anticipation of oncoming lanes clearing, as I lifted the pedal the car lurched into the intersection. The Bolt normally accelerates very gently in L mode when no break is applied, but does not lurch forwards like this under normal conditions. The breaks did work, and I was able to stop, but I was now in the middle of the intersection and slightly encroaching into oncoming lanes. I tried t

While waiting to turn left at a light and driving in "L" (one pedal) mode, I started to release the break in anticipation of oncoming lanes clearing, as I lifted the pedal the car lurched into the intersection. The Bolt normally accelerates very gently in L mode when no break is applied, but does not lurch forwards like this under normal conditions. The breaks did work, and I was able to stop, but I was now in the middle of the intersection and slightly encroaching into oncoming lanes. I tried t

While waiting to turn left at a light and driving in "L" (one pedal) mode, I started to release the break in anticipation of oncoming lanes clearing, as I lifted the pedal the car lurched into the intersection. The Bolt normally accelerates very gently in L mode when no break is applied, but does not lurch forwards like this under normal conditions. The breaks did work, and I was able to stop, but I was now in the middle of the intersection and slightly encroaching into oncoming lanes. I tried t

See attached document for complaint.

See attached document for complaint.

What component or system failed or malfunctioned, and is it available for inspection upon request? The vehicle’s steering system (specifically the electric power steering assist and/or steering rack assembly) began exhibiting stiffness, resistance, and intermittent loss of assist while turning. The steering system is still installed on the vehicle and is available for inspection upon request by NHTSA, GM, or a dealer representative. ⸻ How was your safety or the safety of others put at ris

Steering very stiff will not return to center on its own. Seems to be the steering rack. Not returning to center seems dangerous in certain situations. This is a 2020 vehicle but seems to be a common problem on all years Bolt EV/EUV.

High-voltage battery failure left Bolt EV immobilized after recall fix: Our 2020 Chevrolet Bolt EV (VIN: [XXX] ) became completely immobilized on [XXX], due to high-voltage battery failure. The vehicle previously underwent all recall remedies, including a full propulsion battery replacement in May 2023, but less than two years later the same issue has reoccurred. This failure left us stranded and unable to operate the car. Loss of propulsion without warning presents a serious safety risk, parti

High-voltage battery failure left Bolt EV immobilized after recall fix: Our 2020 Chevrolet Bolt EV (VIN: [XXX] ) became completely immobilized on [XXX], due to high-voltage battery failure. The vehicle previously underwent all recall remedies, including a full propulsion battery replacement in May 2023, but less than two years later the same issue has reoccurred. This failure left us stranded and unable to operate the car. Loss of propulsion without warning presents a serious safety risk, parti

The contact owns a 2020 Chevrolet Bolt EV. The contact stated that while the vehicle was parked unattended, the vehicle exploded. The contact believed the failure was due to the battery. The front left tire message was displayed. The battery was previously replaced. The local dealer was contacted regarding the battery purchase. The vehicle was not diagnosed or repaired. The contact called another local dealer. La Quinta Chevy Cady Service, 79225 CA-111, La Quinta, CA 92253, to obtain the servic

Mileage: 53,030

The contact owns a 2020 Chevrolet Bolt EV. The contact stated that while the vehicle was parked unattended, the vehicle exploded. The contact believed the failure was due to the battery. The front left tire message was displayed. The battery was previously replaced. The local dealer was contacted regarding the battery purchase. The vehicle was not diagnosed or repaired. The contact called another local dealer. La Quinta Chevy Cady Service, 79225 CA-111, La Quinta, CA 92253, to obtain the servic

Mileage: 53,030

The contact owns a 2020 Chevrolet Bolt EV. The contact stated that while the vehicle was parked unattended, the vehicle exploded. The contact believed the failure was due to the battery. The front left tire message was displayed. The battery was previously replaced. The local dealer was contacted regarding the battery purchase. The vehicle was not diagnosed or repaired. The contact called another local dealer. La Quinta Chevy Cady Service, 79225 CA-111, La Quinta, CA 92253, to obtain the servic

Mileage: 53,030

The steering wheel fails to return to center after turns. This requires constant manual correction to re-center the vehicle, which increases the risk of overcorrection or unintended lane departure. There are no warning lights or noise, and the issue does not appear to be related to alignment, tires, or pressure. Many other Chevrolet Bolt owners are reporting the same behavior, pointing to a potential defect in the steering gear or rack. This is an very serious safety hazard that could result in

The steering wheel intermittently sticks and fails to return to center after turns or minor corrections, especially at low to moderate speeds. This requires constant manual correction to re-center the vehicle, which increases the risk of overcorrection or unintended lane departure. There are no warning lights or noise, and the issue does not appear to be related to alignment, tires, or pressure. Many other Chevy Bolt owners are reporting the same behavior, pointing to a potential defect in the s

The backup/360 camera intermittently but frequently fails to turn on, showing a black screen instead with a crossed out camera icon. This makes it very difficult to back up safely and puts bystanders at risk. This problem has not yet been evaluated by a dealer, but there are numerous other reports of the issue online. There have been no other warning lights or issues.

The car has 80,000 miles. The backup camera has always had an intermittent issue after rain but now has stopped working. I cannot see properly to back up. I understand that this is an issue with quite a few Chevy Bolts and can/has caused problems with backing accidents. I also understand that the company has known about this for a while, but has done nothing about the issue.

Steering would not return to center after a turn only for LEFT turns, even at higher speeds. Steering would be sticky at low speeds. Resulted in challenging to predict cornering particularly for left turns. Manufacturer replaced steering gear under warranty. OK now.

I first noticed an issue with the steering wheel not returning to center after a turn, and also when in a slow sweeping curve that the wheel would hold the position and keep in the turn/curve unless corrected by manually turning it straight. I had new tires installed on 11/6/2024 and the alignment was checked and was correct. The tires that I chose turned out to be way harsher riding and noisy then the OEM's so I went with a different tire that was more EV specific. Nothing changed in regards to

Right brake caliper sticking intermittently, causing massive vibration in steering wheel and a caliper too hot to touch. In doing research on the Chevy Bolt forum, there were many people talking about this issue. In fact, GM issued a TSB about this issue, but when I entered my VIN in the GM site, it said that my VIN as not impacted; however, it was! I suggest that the NTSB do a further investigation to include all VINs affected with this issue. I had to spend several hundred dollars for a repai